2003 Alfa Romeo GTV Engine Parts

This table covers the seals at each camshaft end. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

3 Camshaft Seal parts for the 2003 Alfa Romeo GTV come from 2 brands — ELRING and AJUSA.

Part numbers include AJUSA 15010900, ELRING 325155 and ELRING 325156.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

One part is listed for the 2003 Alfa Romeo GTV — AJUSA 54090000.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

2 Crankshaft Seal parts for the 2003 Alfa Romeo GTV come from AJUSA.

Listed part numbers: AJUSA 15062800 and AJUSA 15073600.

This table covers the bolts that clamp the cylinder head to the block. Read more

One part is listed for the 2003 Alfa Romeo GTV — AJUSA 81048300.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

AJUSA supplies the 4 Cylinder Head Gasket parts for the 2003 Alfa Romeo GTV.

Listed part numbers: AJUSA 10120500, AJUSA 10120600 and AJUSA 52323100, plus the other parts above.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

One part is listed for the 2003 Alfa Romeo GTV — AJUSA 52161000.

This table covers the wear sleeves used to restore a Cylinder seal surface. Read more

One part is listed for the 2003 Alfa Romeo GTV — AJUSA 60005400.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

One part is listed for the 2003 Alfa Romeo GTV — AJUSA 50174200.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2003 Alfa Romeo GTV — AJUSA 13117500.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2003 Alfa Romeo GTV — ELRING 128503.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

2 Oil Filter parts for the 2003 Alfa Romeo GTV come from 2 brands — MANN and WIX.

Listed part numbers: MANN W7142 and WIX 57503.

This table covers the gaskets that seal the valve cover to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

6 Valve Cover Gasket parts for the 2003 Alfa Romeo GTV come from 2 brands — ELRING and AJUSA. The "Popular" part is ELRING 375270.

This group includes ELRING 375270, ELRING 375080 and AJUSA 56024400 and the remaining parts above.

This table covers the lifters / tappets that transfer cam motion to the valves. Read more

This group shows a single part: AJUSA 85010000.

This table covers the seals on each valve stem that control oil into the guides. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

3 Valve Stem Seal parts for the 2003 Alfa Romeo GTV come from 2 brands — ELRING and AJUSA.

Part numbers include AJUSA 57056600, ELRING 701289 and ELRING 825050.