2018 Chevrolet Express Pasajeros Engine Parts

This table covers the Camshaft bearings. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

4 Camshaft Bearing parts for the 2018 Chevrolet Express Pasajeros come from KING ENGINE BEARINGS.

Part numbers include KING ENGINE BEARINGS CS5171BB, KING ENGINE BEARINGS CS5171HP and KING ENGINE BEARINGS CS5172HP, among others listed above.

This table covers the Camshaft Retainer / Thrust plates. Typical signs include warpage, cracks, or a plate that no longer locates the assembly. Confirm which plate the notes describe — backing plates, clutch plates and strike plates are different parts. Read more

One part is listed for the 2018 Chevrolet Express Pasajeros — DORMAN 45745.

This table covers the seals at each camshaft end. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

One part is listed for the 2018 Chevrolet Express Pasajeros — AJUSA 01713900.

This table covers the bearings in the connecting-rod big ends. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

11 Connecting Rod Bearing parts for the 2018 Chevrolet Express Pasajeros come from KING ENGINE BEARINGS. The "Popular" part is KING ENGINE BEARINGS CR807XPN.

The High Performance section lists 6 options from KING ENGINE BEARINGS — engineered beyond original-equipment specification. KING ENGINE BEARINGS CR807XPN is listed in this group.

In the Standard Replacement grade, KING ENGINE BEARINGS supplies 3 parts: built to original-equipment specification. A representative part number is KING ENGINE BEARINGS CR807SI.

2 further parts sit outside the graded sections, with the same engine-level match.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

This group shows a single part: AJUSA 54290500.

This table covers the main bearings that support the crankshaft in the block. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

KING ENGINE BEARINGS supplies the 10 Crankshaft Main Bearing parts for the 2018 Chevrolet Express Pasajeros. KING ENGINE BEARINGS MB5013XP carries the "Popular" badge.

High Performance: 6 parts, from KING ENGINE BEARINGS. A representative part number is KING ENGINE BEARINGS MB5013XP.

The Standard Replacement section: 4 options from KING ENGINE BEARINGS. KING ENGINE BEARINGS MB5293SI is listed in this group.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

AJUSA supplies the 3 Crankshaft Seal parts for the 2018 Chevrolet Express Pasajeros.

This group includes AJUSA 15113900, AJUSA 15113800 and AJUSA 77082800.

This table covers the Crankshaft Seal covers. Read more

2 Crankshaft Seal Cover parts for the 2018 Chevrolet Express Pasajeros come from 2 brands — DORMAN and SKP.

Listed part numbers: DORMAN 635518 and SKP SK635518.

This table covers the Crankshaft Seal Cover tools. This is a service tool, not a wear part — match the application in the notes. Read more

This group shows a single part: DORMAN 635000.

This table covers the cylinder heads that close the top of the block. Read more

One part is listed for the 2018 Chevrolet Express Pasajeros — CYLINDER HEAD EXPRESS CI530B.

This table covers the bolts that clamp the cylinder head to the block. Read more

This group shows a single part: AJUSA 81073600.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

3 Cylinder Head Gasket parts for the 2018 Chevrolet Express Pasajeros come from AJUSA.

Part numbers include AJUSA 10263300, AJUSA 52637600 and AJUSA 52637700.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

This group shows a single part: AJUSA 52637500.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

This group shows a single part: AJUSA 50565900.

This table covers the crankshaft pulleys / harmonic balancers at the front of the engine. Read more

2 Harmonic Balancer parts for the 2018 Chevrolet Express Pasajeros come from 2 brands — SKP and DORMAN.

The Economy section lists 1 option from SKP — the catalog's value-priced group. SKP SK594209 is listed in this group.

Standard Replacement: 1 part, from DORMAN. A representative part number is DORMAN 594209.

Part numbers include SKP SK594209 and DORMAN 594209.

This table covers the Harmonic Balancer bolts. Read more

One part is listed for the 2018 Chevrolet Express Pasajeros — DORMAN 917139.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Intake Manifold Gasket parts for the 2018 Chevrolet Express Pasajeros come from AJUSA.

Part numbers include AJUSA 13298000 and AJUSA 77059100.

This table covers the mounts that hold the engine to the chassis. Typical signs include a clunk on takeoff, a vibration at idle, or a separated rubber insert. Support the powertrain before unbolting a mount, and torque the fasteners in the notes. Read more

2 Motor Mount parts are listed for the 2018 Chevrolet Express Pasajeros, from ANCHOR and DEA / MARMON RIDE CONTROL.

Listed part numbers: ANCHOR 3178 and DEA / MARMON RIDE CONTROL A5109.

This table covers the Motor Mount kits. Read more

One part is listed for the 2018 Chevrolet Express Pasajeros — ANCHOR 300034.

This table covers the gaskets that seal the Oil Cooler. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

This group shows a single part: DORMAN 66219.

This table covers the Oil Cooler lines. Typical signs include a wet fitting, a rusted pipe, or a pressure loss in this circuit. Flare or thread the new line the way the notes specify; a kinked replacement will fail early. Read more

One part is listed for the 2018 Chevrolet Express Pasajeros — DORMAN 625522.

This table covers the harness connectors at the Oil Cooler Line. Typical signs include an intermittent fault that moves when you wiggle the plug, green corrosion, or a melted housing. Match terminal count and keyway, not just color. Many families look identical and will not lock. Read more

This group shows a single part: DORMAN 800622.

This table covers the Oil Dipstick tubes. Read more

2 Oil Dipstick / Tube parts are listed for the 2018 Chevrolet Express Pasajeros, from DORMAN and SKP.

Part numbers include DORMAN 917433 and SKP SK917433.

This table covers the drain plugs in the oil pan. Read more

DORMAN supplies the 3 Oil Drain Plug parts for the 2018 Chevrolet Express Pasajeros.

Economy: 1 part, from DORMAN. A representative part number is DORMAN 090175.

The Twist Drain section lists 1 option from DORMAN — grouped under the catalog's "Twist Drain" designation — the notes column spells out what sets them apart. DORMAN 092018 is listed in this group.

1 ungrouped part is not assigned to a grade, with the same engine-level match.

Part numbers include DORMAN 090175, DORMAN 092018 and DORMAN 090034.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

3 Oil Drain Plug Gasket parts for the 2018 Chevrolet Express Pasajeros come from 2 brands — DORMAN and AJUSA.

Part numbers include AJUSA 01148400, DORMAN 097119 and DORMAN 97119.

This table covers the caps on the oil filler neck. Read more

2 Oil Filler Cap parts are listed for the 2018 Chevrolet Express Pasajeros, from GATES and MOTORAD.

Part numbers include GATES 31103 and MOTORAD MO99.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

11 Oil Filter parts are listed for the 2018 Chevrolet Express Pasajeros, from VARIOUS MFR, WIX, ACDELCO and 5 other brands. MOBIL M1113A carries the "Popular" badge.

Economy: 4 parts, from FVP, PRO-TEC, PUROLATOR and 1 other brand. A representative part number is FVP R7060.

In the High Performance / Heavy Duty grade, MOBIL and WIX supply 2 parts: grouped under the catalog's "High Performance / Heavy Duty" designation — the notes column spells out what sets them apart. A representative part number is MOBIL M1113A.

The Standard Replacement section: 5 options from ACDELCO, WIX, MAHLE / CLEVITE and 1 other brand. WIX 57060 is listed in this group.

This table covers the oil pans that hold the engine's oil sump. Read more

3 Oil Pan parts for the 2018 Chevrolet Express Pasajeros come from 3 brands — DORMAN, SKP and SPECTRA PREMIUM.

This group includes DORMAN 264375, SKP SK264375 and SPECTRA PREMIUM GMP53C.

This table covers the gaskets between the oil pan and the block. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2018 Chevrolet Express Pasajeros — AJUSA 14108100.

This table covers the Oil Sump plates. Typical signs include warpage, cracks, or a plate that no longer locates the assembly. Confirm which plate the notes describe — backing plates, clutch plates and strike plates are different parts. Read more

This group shows a single part: DORMAN 99971.

This table covers the Timing covers. Read more

This group shows a single part: DORMAN 635517.

This table covers the Valley Pan covers. Read more

This group shows a single part: DORMAN 615266.

This table covers the Valve covers. Read more

4 Valve Cover parts for the 2018 Chevrolet Express Pasajeros come from 2 brands — DORMAN and SKP.

Part numbers include DORMAN 264994, DORMAN 264969 and SKP SK264994, among others listed above.

This table covers the gaskets that seal the valve cover to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

AJUSA supplies both parts for the 2018 Chevrolet Express Pasajeros.

This group includes AJUSA 11151800 and AJUSA 77084200.

This table covers the seals on each valve stem that control oil into the guides. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

AJUSA supplies the 3 Valve Stem Seal parts for the 2018 Chevrolet Express Pasajeros.

This group includes AJUSA 12039000, AJUSA 12041500 and AJUSA 57093600.

This table covers the oil-control solenoids that command the cam phasers. Typical signs include a door or range that will not move, or a click with no motion. Confirm the command signal before replacing the actuator — a failed module looks the same. Read more

5 Variable Valve Timing (VVT) Solenoid / Actuator parts are listed for the 2018 Chevrolet Express Pasajeros, from DORMAN, GATES, ROSTRA and 1 other brand. MELLING VCTO1000 carries the "Popular" badge.

Economy: 4 parts, from DORMAN, GATES and ROSTRA. A representative part number is DORMAN 916865.

The Standard Replacement section: 1 option from MELLING. MELLING VCTO1000 is listed in this group.

Part numbers include MELLING VCTO1000, DORMAN 916865 and DORMAN 916886XD, among others listed above.

This table covers the cam phaser sprockets used by the variable-valve-timing system. Read more

2 Variable Valve Timing (VVT) Sprocket parts are listed for the 2018 Chevrolet Express Pasajeros, from DORMAN and GATES.

Economy: 1 part, from DORMAN. A representative part number is DORMAN 918186.

The Standard Replacement section: 1 option from GATES. GATES VCP855 is listed in this group.

This group includes DORMAN 918186 and GATES VCP855.