2004 Chrysler Crossfire Cooling System Parts

This table covers the engine coolants and antifreeze formulations specified for this cooling system. Typical signs include a rising temperature gauge, rusty or sludged coolant, or a heater that blows cold. Use the chemistry named in the notes. Mixing silicate, OAT and HOAT formulas can gel in the radiator. Read more

18 Coolant / Antifreeze parts for the 2004 Chrysler Crossfire come from 6 brands — PRESTONE, VALVOLINE, PEAK and 3 other brands. The "Popular" part is FVP MV5050GAL.

In the Compatible With All Colors grade, PRESTONE supplies 1 part: grouped under the catalog's "Compatible With All Colors" designation — the notes column spells out what sets them apart. A representative part number is PRESTONE AF3055.

The Economy section lists 4 options from FVP, PEAK, PRESTONE and 1 other brand — the catalog's value-priced group. FVP MV5050GAL is listed in this group.

In the Premium grade, PRESTONE and PEAK supply 5 parts: a step above OE specification in materials, tolerances or warranty terms. A representative part number is PRESTONE AF2100.

In the Standard Replacement grade, VALVOLINE, PRESTONE, ACDELCO and 2 other brands supply 8 parts: built to original-equipment specification. A representative part number is ACDELCO 105027.

This table covers the hard pipes and extra hoses in the coolant circuit. Read more

This group shows a single part: MOPAR 5097893AA.

This table covers the Coolant Level sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

2 Coolant Level Sensor parts for the 2004 Chrysler Crossfire come from 2 brands — GPD and MOPAR.

Part numbers include GPD 1712645 and MOPAR 5098768AA.

This table covers the overflow / expansion tanks that hold extra coolant. Read more

One part is listed for the 2004 Chrysler Crossfire — MOPAR 5101601AA.

This table covers the caps on the overflow / expansion tank. Typical signs include a leak at the neck, a cap that will not hold pressure, or a missing tether. Match the pressure rating or thread in the notes — radiator, reservoir and fuel caps are not interchangeable. Read more

One part is listed for the 2004 Chrysler Crossfire — CALORSTAT RC0160.

This table covers the Cooling Fan control modules. Read more

4 Cooling Fan Control Module parts are listed for the 2004 Chrysler Crossfire, from GATES, BECK/ARNLEY and WELLS.

Part numbers include BECK/ARNLEY 2030285, GATES FCM127 and GATES FCM127K, among others listed above.

This table covers the radiators that dump engine heat to airflow through the core. Typical signs include overheating in traffic, a wet core, or coolant that disappears with no puddle. Replace the cap if it cannot hold the rated pressure, and bleed the system after the swap. Read more

8 Radiator parts for the 2004 Chrysler Crossfire come from 8 brands — TECHPRO, SPECTRA PREMIUM, UAC and 5 other brands. The "Popular" part is SPECTRA PREMIUM CU2651.

The Economy section: 1 option from TECHPRO. TECHPRO CH3010298 is listed in this group.

Standard Replacement: 7 parts, from SPECTRA PREMIUM, UAC, AGILITY and 4 other brands. A representative part number is SPECTRA PREMIUM CU2651.

This group includes SPECTRA PREMIUM CU2651, TECHPRO CH3010298 and UAC RA2651C and the remaining parts above.

This table covers the caps that hold system pressure at the radiator or reservoir neck. Typical signs include a leak at the neck, a cap that will not hold pressure, or a missing tether. Match the pressure rating or thread in the notes — radiator, reservoir and fuel caps are not interchangeable. Read more

This group shows a single part: MOPAR 5099248AA.

This table covers the fan assemblies (and clutches, where listed) that pull air through the radiator. Read more

6 Radiator Fan Assembly parts are listed for the 2004 Chrysler Crossfire, from DORMAN, GPD, FOUR SEASONS and 3 other brands. DORMAN 620040 carries the "Popular" badge.

Economy: 2 parts, from DORMAN and GPD. A representative part number is DORMAN 620040.

The Standard Replacement section: 4 options from FOUR SEASONS, NISSENS, UAC and 1 other brand. FOUR SEASONS 75931 is listed in this group.

Part numbers include DORMAN 620040, GPD 2811785 and FOUR SEASONS 75931, among others listed above.

This table covers the upper, lower and connecting hoses between radiator, engine and reservoir. Typical signs include swelling, cracks, a soft spot, or a leak at a clamp. Replace adjacent aged hoses while the system is drained — they share the same heat cycle. Read more

6 Radiator Hose parts are listed for the 2004 Chrysler Crossfire, from MOPAR, DAYCO, GATES and 2 other brands. DAYCO 72007 carries the "Popular" badge.

This group includes DAYCO 72007, GATES 22575 and ACDELCO 22400M and the remaining parts above.

This table covers the Radiator Mount bushings. Typical signs include a clunk over bumps, or a torn or walked-out bushing you can see. Press the new bushing square. A cocked bushing will tear in a few thousand miles. Read more

One part is listed for the 2004 Chrysler Crossfire — MOPAR 5097872AA.

This table covers the seals at the Radiator. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

One part is listed for the 2004 Chrysler Crossfire — MOPAR 5099412AA.

This table covers the senders that report coolant temperature to the gauge or ECU. Typical signs include a gauge that sits on empty or overheat, or a lamp that does not match what the engine is doing. Rule out the cluster and the wiring before replacing the sender. Read more

17 Temperature Sender / Sensor parts for the 2004 Chrysler Crossfire come from 15 brands — HOLSTEIN, STANDARD MOTOR PRODUCTS, SKP and 12 other brands. The "Popular" part is HOLSTEIN 2CTS0182.

The Economy section: 9 options from HOLSTEIN, SKP, STANDARD MOTOR PRODUCTS and 5 other brands. HOLSTEIN 2CTS0182 is listed in this group.

Standard Replacement: 8 parts, from STANDARD MOTOR PRODUCTS, BECK/ARNLEY, FOUR SEASONS and 5 other brands. A representative part number is STANDARD MOTOR PRODUCTS TS615.

This table covers the thermostats that open the coolant circuit at the specified temperature. Typical signs include slow warm-up, a gauge that climbs in traffic, or heat that never quite arrives. Replace the housing gasket with the thermostat and bleed the system so a trapped air pocket does not cook the new part. Read more

6 Thermostat parts are listed for the 2004 Chrysler Crossfire, from GATES, MOTORAD, CALORSTAT and 3 other brands. GATES 33930 carries the "Popular" badge.

Part numbers include GATES 33930, MOTORAD 458192 and CALORSTAT TH651387J, among others listed above.

This table covers the seals at the thermostat housing and water outlet. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

4 Thermostat / Thermostat Housing / Water Outlet Seal parts for the 2004 Chrysler Crossfire come from 4 brands — APEX, FEL-PRO, MAHLE / CLEVITE and 1 other brand.

This group includes APEX AWO2286, FEL-PRO 35908 and MAHLE / CLEVITE C31887 and the remaining parts above.

This table covers the pumps that circulate coolant through the block and radiator. Typical signs include coolant at the weep hole, pulley play, or a growl from the front of the engine. Replace the thermostat and refill with the specified coolant whenever the pump comes off. Read more

16 Water Pump parts are listed for the 2004 Chrysler Crossfire, from GMB, SKP, DAYCO and 9 other brands. SKP SK1472250 carries the "Popular" badge.

Economy: 7 parts, from SKP, US MOTOR WORKS, CARDONE and 3 other brands. A representative part number is SKP SK1472250.

The Standard Replacement section: 9 options from GMB, DAYCO, GATES and 3 other brands. GATES 44082 is listed in this group.

This table covers the gaskets between the water pump and the block or housing. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

6 Water Pump Gasket parts for the 2004 Chrysler Crossfire come from 6 brands — FEL-PRO, MAHLE / CLEVITE, AJUSA and 3 other brands. The "Popular" part is FEL-PRO 35910.

This group includes FEL-PRO 35910, MAHLE / CLEVITE K31934 and AJUSA 01058800 and the remaining parts above.

This table covers the Water Pump pulleys. Typical signs include a growl or chirp that follows engine speed, or a pulley that will not spin freely by hand. Spin each pulley with the belt off. Roughness or play means replace it with the belt. Read more

This group shows a single part: MOPAR 5096527AA.