2009 Dodge Sprinter 2500 Cooling System Parts

This table covers the engine coolants and antifreeze formulations specified for this cooling system. Typical signs include a rising temperature gauge, rusty or sludged coolant, or a heater that blows cold. Use the chemistry named in the notes. Mixing silicate, OAT and HOAT formulas can gel in the radiator. Read more

18 Coolant / Antifreeze parts for the 2009 Dodge Sprinter 2500 come from 6 brands — PRESTONE, VALVOLINE, FVP and 3 other brands. The "Popular" part is FVP MV5050GAL.

In the Compatible With All Colors grade, PRESTONE supplies 1 part: grouped under the catalog's "Compatible With All Colors" designation — the notes column spells out what sets them apart. A representative part number is PRESTONE AF3055.

The Economy section lists 3 options from FVP, PRESTONE and VALVOLINE — the catalog's value-priced group. FVP MV5050GAL is listed in this group.

In the Heavy Duty grade, PEAK and PRESTONE supply 2 parts: rated for severe service. A representative part number is PEAK FXA1GAL.

In the Premium grade, PRESTONE supplies 3 parts: a step above OE specification in materials, tolerances or warranty terms. A representative part number is PRESTONE AF2100.

In the Standard Replacement grade, VALVOLINE, PRESTONE, PENTOSIN and 2 other brands supply 9 parts: built to original-equipment specification. A representative part number is ACDELCO 105027.

This table covers the hard pipes and extra hoses in the coolant circuit. Read more

4 Coolant Hose / Pipe parts for the 2009 Dodge Sprinter 2500 come from 3 brands — ACDELCO, GATES and REIN.

Listed part numbers: ACDELCO 14920S, ACDELCO 14924S and GATES 12189, plus the other parts above.

This table covers the seals at the Coolant Hose Connector / Flange. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

One part is listed for the 2009 Dodge Sprinter 2500 — ELRING 540890.

This table covers the Coolant Level sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

2 Coolant Level Sensor parts for the 2009 Dodge Sprinter 2500 come from 2 brands — MOPAR and STANDARD MOTOR PRODUCTS.

This group includes MOPAR 68013657AA and STANDARD MOTOR PRODUCTS FLS278.

This table covers the overflow / expansion tanks that hold extra coolant. Read more

7 Coolant Reservoir parts are listed for the 2009 Dodge Sprinter 2500, from REIN, DORMAN, GPD and 3 other brands. DORMAN 603836 carries the "Popular" badge.

Part numbers include DORMAN 603836, REIN EPK0143 and GPD 2411283, among others listed above.

This table covers the caps on the overflow / expansion tank. Typical signs include a leak at the neck, a cap that will not hold pressure, or a missing tether. Match the pressure rating or thread in the notes — radiator, reservoir and fuel caps are not interchangeable. Read more

3 Coolant Reservoir Cap parts are listed for the 2009 Dodge Sprinter 2500, from CALORSTAT, REIN and STANT.

Part numbers include CALORSTAT RC0167, REIN CPE0040 and STANT 10252.

This table covers the adapters used to pressure-test this cooling system. Read more

This group shows a single part: GATES 31371.

This table covers the Hose clamps. Read more

This group shows a single part: MOPAR 5124716AA.

This table covers the intercoolers that cool turbo or supercharger charge air. Read more

9 Intercooler parts for the 2009 Dodge Sprinter 2500 come from 9 brands — NISSENS, TYC, AGILITY and 6 other brands. The "Popular" part is NISSENS 96628.

This group includes NISSENS 96628, TYC 18075 and AGILITY 5010006 and the remaining parts above.

This table covers the Intercooler Air Hose pipes. Read more

5 Intercooler Air Hose / Pipe parts for the 2009 Dodge Sprinter 2500 come from 3 brands — REIN, GATES and ACDELCO. The "Popular" part is REIN TCH0301.

Listed part numbers: REIN TCH0301 and ACDELCO 26267, plus the other parts above.

This table covers the radiators that dump engine heat to airflow through the core. Typical signs include overheating in traffic, a wet core, or coolant that disappears with no puddle. Replace the cap if it cannot hold the rated pressure, and bleed the system after the swap. Read more

10 Radiator parts for the 2009 Dodge Sprinter 2500 come from 10 brands — GPD, CSF, SPECTRA PREMIUM and 7 other brands. The "Popular" part is CSF 3660.

The Economy section: 1 option from GPD. GPD 13254C is listed in this group.

Standard Replacement: 8 parts, from CSF, SPECTRA PREMIUM, AGILITY and 5 other brands. A representative part number is CSF 3660.

1 further part sits outside the graded sections, with the same engine-level match.

This table covers the caps that hold system pressure at the radiator or reservoir neck. Typical signs include a leak at the neck, a cap that will not hold pressure, or a missing tether. Match the pressure rating or thread in the notes — radiator, reservoir and fuel caps are not interchangeable. Read more

This group shows a single part: GATES 31538.

This table covers the Radiator Fan blades. Typical signs include chatter, streaks, or a skip at the top of the stroke. Confirm left and right lengths in the notes — they are often different. Read more

One part is listed for the 2009 Dodge Sprinter 2500 — MOPAR 68012412AA.

This table covers the Radiator Fan clutches. Typical signs include slip at highway speed, chatter on takeoff, or a pedal that stays low. Resurface or replace the flywheel with the clutch — a heat-checked flywheel wastes the new disc. Read more

5 Radiator Fan Clutch parts for the 2009 Dodge Sprinter 2500 come from 5 brands — US MOTOR WORKS, FOUR SEASONS, GMB and 2 other brands. The "Popular" part is US MOTOR WORKS 22333.

This group includes US MOTOR WORKS 22333, FOUR SEASONS 46105 and GMB 9202670 and the remaining parts above.

This table covers the brackets that mount the Radiator Fan Clutch Bearing. Typical signs include a cracked mount, a rattle, or a bracket that no longer holds alignment. Confirm position in the notes. Many brackets look alike and bolt to different corners. Read more

2 Radiator Fan Clutch Bearing Bracket parts for the 2009 Dodge Sprinter 2500 come from 2 brands — GATES and SKP.

Listed part numbers: GATES FB1018 and SKP SKFB1018.

This table covers the shrouds that duct air through the fan and radiator. Read more

This group shows a single part: MOPAR 68013658AA.

This table covers the upper, lower and connecting hoses between radiator, engine and reservoir. Typical signs include swelling, cracks, a soft spot, or a leak at a clamp. Replace adjacent aged hoses while the system is drained — they share the same heat cycle. Read more

8 Radiator Hose parts are listed for the 2009 Dodge Sprinter 2500, from DAYCO, GATES, REIN and 2 other brands. DAYCO 72757 carries the "Popular" badge.

Listed part numbers: DAYCO 72757, GATES 24199 and ACDELCO 20703S, plus the other parts above.

This table covers the senders that report coolant temperature to the gauge or ECU. Typical signs include a gauge that sits on empty or overheat, or a lamp that does not match what the engine is doing. Rule out the cluster and the wiring before replacing the sender. Read more

18 Temperature Sender / Sensor parts for the 2009 Dodge Sprinter 2500 come from 13 brands — GPD, STANDARD MOTOR PRODUCTS, VEMO and 10 other brands. The "Popular" part is HOLSTEIN 2CTS0182.

The Economy section: 8 options from GPD, VEMO, HOLSTEIN and 2 other brands. HOLSTEIN 2CTS0182 is listed in this group.

Standard Replacement: 10 parts, from WALKER PRODUCTS, STANDARD MOTOR PRODUCTS, BECK/ARNLEY and 6 other brands. A representative part number is STANDARD MOTOR PRODUCTS TX155.

This table covers the thermostats that open the coolant circuit at the specified temperature. Typical signs include slow warm-up, a gauge that climbs in traffic, or heat that never quite arrives. Replace the housing gasket with the thermostat and bleed the system so a trapped air pocket does not cook the new part. Read more

5 Thermostat parts are listed for the 2009 Dodge Sprinter 2500, from DORMAN, REIN, FOUR SEASONS and 2 other brands. REIN CTA0071 carries the "Popular" badge.

Economy: 1 part, from DORMAN. A representative part number is DORMAN 9023043.

The Standard Replacement section: 4 options from REIN, FOUR SEASONS, MAHLE / CLEVITE and 1 other brand. REIN CTA0071 is listed in this group.

This group includes REIN CTA0071, DORMAN 9023043 and FOUR SEASONS 86107 and the remaining parts above.

This table covers the seals at the thermostat housing and water outlet. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

3 Thermostat / Thermostat Housing / Water Outlet Seal parts for the 2009 Dodge Sprinter 2500 come from 3 brands — APEX, FEL-PRO and MOPAR.

Part numbers include APEX AWO2393, FEL-PRO 36081 and MOPAR 5175584AA.

This table covers the pumps that circulate coolant through the block and radiator. Typical signs include coolant at the weep hole, pulley play, or a growl from the front of the engine. Replace the thermostat and refill with the specified coolant whenever the pump comes off. Read more

10 Water Pump parts are listed for the 2009 Dodge Sprinter 2500, from FVP, ÜRO PARTS, US MOTOR WORKS and 7 other brands. GATES 42283 carries the "Popular" badge.

Economy: 3 parts, from FVP, ÜRO PARTS and US MOTOR WORKS. A representative part number is FVP US6155.

The Standard Replacement section: 7 options from GATES, GMB, ACDELCO and 4 other brands. GATES 42283 is listed in this group.

This table covers the gaskets between the water pump and the block or housing. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

4 Water Pump Gasket parts for the 2009 Dodge Sprinter 2500 come from 4 brands — APEX, ELRING, FEL-PRO and 1 other brand.

This group includes APEX AWP3312, ELRING 540880 and FEL-PRO 36080 and the remaining parts above.