1991 Eagle Talon Engine Parts

This table covers the Balance Shaft bearings. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

6 Balance Shaft Bearing parts for the 1991 Eagle Talon come from 5 brands — ITM ENGINE COMPONENTS, MAHLE / CLEVITE, SEALED POWER and 2 other brands. The "Popular" part is MAHLE / CLEVITE SH1469S.

Listed part numbers: MAHLE / CLEVITE SH1469S, SEALED POWER 1810M and ENGINETECH BS1811, plus the other parts above.

This table covers the Balance Shaft belts. Typical signs include squeal on cold start, cracked ribs, or glazing. Spin the tensioner and idlers by hand while the belt is off. Read more

12 Balance Shaft Belt parts are listed for the 1991 Eagle Talon, from CLOYES, ITM ENGINE COMPONENTS, PREFERRED COMPONENTS INC and 9 other brands. CLOYES B168 carries the "Popular" badge.

In the Economy grade, CLOYES, ITM ENGINE COMPONENTS, PREFERRED COMPONENTS INC and 2 other brands supply 5 parts: the catalog's value-priced group. A representative part number is CLOYES B168.

The Standard Replacement section lists 6 options from DAYCO, GATES, ACDELCO and 3 other brands — built to original-equipment specification. DAYCO 95168 is listed in this group.

1 ungrouped part is not assigned to a grade, with the same engine-level match.

This table covers the Balance Shaft Belt tensioners. Typical signs include belt flutter, a chirp that returns after a new belt, or an arm that no longer damps. Replace the tensioner with the belt at higher mileage. Read more

5 Balance Shaft Belt Tensioner parts for the 1991 Eagle Talon come from 5 brands — CLOYES, GATES, GMB and 2 other brands. The "Popular" part is CLOYES 95197.

This group includes CLOYES 95197, GATES T41047 and GMB 4481070 and the remaining parts above.

This table covers the wear sleeves used to restore a Balance Shaft seal surface. Read more

2 Balance Shaft Repair Sleeve parts are listed for the 1991 Eagle Talon, from NATIONAL and WJB / INMOTION PARTS.

Part numbers include NATIONAL 99098 and WJB / INMOTION PARTS WS99098.

This table covers the seals at the Balance Shaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

4 Balance Shaft Seal parts are listed for the 1991 Eagle Talon, from JAPANESE OE, NATIONAL and WJB / INMOTION PARTS.

Listed part numbers: JAPANESE OE KJ413209, JAPANESE OE F4225 and NATIONAL 712007, plus the other parts above.

This table covers the camshafts that open the valves. Read more

3 Camshaft parts are listed for the 1991 Eagle Talon, from BECK/ARNLEY, ENGINETECH and TOPLINE.

Part numbers include BECK/ARNLEY 0200164, ENGINETECH ES1512 and TOPLINE CAMMI6E.

This table covers the Camshaft bearings. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

2 Camshaft Bearing parts are listed for the 1991 Eagle Talon, from DURA-BOND and KING ENGINE BEARINGS.

This group includes DURA-BOND MIG3 and KING ENGINE BEARINGS CS3305BB.

This table covers the wear sleeves used to restore a Camshaft seal surface. Read more

4 Camshaft Repair Sleeve parts for the 1991 Eagle Talon come from 4 brands — BCA, NATIONAL, TIMKEN and 1 other brand.

This group includes BCA NS99139, NATIONAL 99139 and TIMKEN KWK99139 and the remaining parts above.

This table covers the seals at each camshaft end. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

12 Camshaft Seal parts for the 1991 Eagle Talon come from 11 brands — FEL-PRO, NATIONAL, TIMKEN and 8 other brands. The "Popular" part is FEL-PRO TCS45483.

This table covers the Circular / Semi-Circular plugs. Typical signs include a leak at the drain or glow-plug hole, or a plug that has rounded off. Replace the crush washer and torque to the spec in the notes. Read more

3 Circular / Semi-Circular Plug parts for the 1991 Eagle Talon come from 3 brands — APEX, FEL-PRO and VICTOR REINZ.

This group includes APEX ACP200, FEL-PRO CP75013 and VICTOR REINZ 711349400.

This table covers the bearings in the connecting-rod big ends. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

9 Connecting Rod Bearing parts are listed for the 1991 Eagle Talon, from KING ENGINE BEARINGS, MAHLE / CLEVITE, SEALED POWER and 1 other brand. MAHLE / CLEVITE CB1120A carries the "Popular" badge.

In the High Performance grade, KING ENGINE BEARINGS and MAHLE / CLEVITE supply 4 parts: engineered beyond original-equipment specification. A representative part number is KING ENGINE BEARINGS CR4481XP.

The Standard Replacement section: 5 options from MAHLE / CLEVITE, KING ENGINE BEARINGS, SEALED POWER and 1 other brand. MAHLE / CLEVITE CB1120A is listed in this group.

Part numbers include MAHLE / CLEVITE CB1120A, KING ENGINE BEARINGS CR4481XP and KING ENGINE BEARINGS CR4481XPC, among others listed above.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

5 Conversion / Lower Gasket Set parts are listed for the 1991 Eagle Talon, from APEX, FEL-PRO, MAHLE / CLEVITE and 2 other brands. APEX ACS2003 carries the "Popular" badge.

Listed part numbers: APEX ACS2003, FEL-PRO CS9086 and MAHLE / CLEVITE CS5875, plus the other parts above.

This table covers the main bearings that support the crankshaft in the block. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

7 Crankshaft Main Bearing parts for the 1991 Eagle Talon come from 5 brands — KING ENGINE BEARINGS, MAHLE / CLEVITE, SEALED POWER and 2 other brands. The "Popular" part is MAHLE / CLEVITE MS2039P.

The High Performance section: 2 options from KING ENGINE BEARINGS. KING ENGINE BEARINGS MB5227XP is listed in this group.

Standard Replacement: 5 parts, from MAHLE / CLEVITE, SEALED POWER, BECK/ARNLEY and 2 other brands. A representative part number is MAHLE / CLEVITE MS2039P.

This group includes MAHLE / CLEVITE MS2039P, KING ENGINE BEARINGS MB5227XP and KING ENGINE BEARINGS MB5227XPX and the remaining parts above.

This table covers the Crankshaft Main Bearing Cap bolts. Read more

One part is listed for the 1991 Eagle Talon — ARP 2075401.

This table covers the sleeves used to restore a grooved crankshaft seal surface. Read more

6 Crankshaft Repair Sleeve parts for the 1991 Eagle Talon come from 6 brands — BCA, FEL-PRO, ENGINETECH and 3 other brands. The "Popular" part is BCA NS99315.

This group includes BCA NS99315, FEL-PRO 16275 and ENGINETECH SS346 and the remaining parts above.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

18 Crankshaft Seal parts for the 1991 Eagle Talon come from 12 brands — FEL-PRO, NATIONAL, TIMKEN and 9 other brands. The "Popular" part is FEL-PRO TCS455651.

This table covers the cylinder heads that close the top of the block. Read more

This group shows a single part: TOPLINE CHVMI6.

This table covers the bolts that clamp the cylinder head to the block. Read more

7 Cylinder Head Bolt parts are listed for the 1991 Eagle Talon, from ARP, ENGINETECH, FEL-PRO and 3 other brands. ENGINETECH HB219 carries the "Popular" badge.

Listed part numbers: ENGINETECH HB219, FEL-PRO ES71175 and APEX AHB203, plus the other parts above.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

7 Cylinder Head Gasket parts are listed for the 1991 Eagle Talon, from APEX, FEL-PRO, AJUSA and 3 other brands. APEX AHG203S carries the "Popular" badge.

This group includes APEX AHG203S, FEL-PRO 9627PT and AJUSA 10078900 and the remaining parts above.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

8 Cylinder Head Gasket Set parts are listed for the 1991 Eagle Talon, from ENGINETECH, FEL-PRO, APEX and 3 other brands. APEX AHS2003 carries the "Popular" badge.

This group includes APEX AHS2003, ENGINETECH MI20HSF and AJUSA 52108100 and the remaining parts above.

This table covers the Cylinder Head plugs. Typical signs include a leak at the drain or glow-plug hole, or a plug that has rounded off. Replace the crush washer and torque to the spec in the notes. Read more

This group shows a single part: DORMAN 565093.

This table covers the Cylinder Head Spacer shims. Read more

2 Cylinder Head Spacer Shim parts are listed for the 1991 Eagle Talon, from ENGINETECH and SBI.

This group includes ENGINETECH CHS1001 and SBI 2302001.

This table covers the wear sleeves used to restore a Cylinder seal surface. Read more

MELLING supplies both parts for the 1991 Eagle Talon.

Part numbers include MELLING CSL617 and MELLING CSL717.

This table covers the block heaters that warm the coolant or oil in cold weather. Read more

This group shows a single part: KAT'S HEATERS 11411.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

5 Engine Kit Gasket Set parts are listed for the 1991 Eagle Talon, from APEX, AJUSA, ENGINETECH and 2 other brands. APEX AFS2003 carries the "Popular" badge.

Part numbers include APEX AFS2003, AJUSA 50122000 and ENGINETECH MI20K3, among others listed above.

This table covers the exhaust valves that let combustion gas out of the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

6 Exhaust Valve parts for the 1991 Eagle Talon come from 6 brands — ENGINETECH, MELLING, QUALCAST and 3 other brands. The "Popular" part is ENGINETECH EM2431.

Part numbers include ENGINETECH EM2431, MELLING V5128 and QUALCAST 1010128, among others listed above.

This table covers the Expansion plugs. Typical signs include a leak at the drain or glow-plug hole, or a plug that has rounded off. Replace the crush washer and torque to the spec in the notes. Read more

6 Expansion Plug parts are listed for the 1991 Eagle Talon, from DORMAN, QUALCAST, ENGINETECH and 1 other brand. DORMAN 555093 carries the "Popular" badge.

This group includes DORMAN 555093, DORMAN 565093 and ENGINETECH PK914 and the remaining parts above.

This table covers the crankshaft pulleys / harmonic balancers at the front of the engine. Read more

4 Harmonic Balancer parts are listed for the 1991 Eagle Talon, from ATP and PIONEER.

Part numbers include ATP 102205, ATP 102082 and PIONEER DA261, among others listed above.

This table covers the Harmonic Balancer bolts. Read more

This group shows a single part: ARP 1071002.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

5 Intake Manifold Gasket parts are listed for the 1991 Eagle Talon, from FEL-PRO, AJUSA, APEX and 2 other brands. FEL-PRO MS94328 carries the "Popular" badge.

This group includes FEL-PRO MS94328, AJUSA 13088900 and APEX AMS2030 and the remaining parts above.

This table covers the intake valves that let air (and fuel, on port-injected engines) into the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

7 Intake Valve parts for the 1991 Eagle Talon come from 7 brands — ENGINETECH, MELLING, ITM ENGINE COMPONENTS and 4 other brands. The "Popular" part is ENGINETECH IM2400.

Listed part numbers: ENGINETECH IM2400, MELLING V5126 and ITM ENGINE COMPONENTS RV9389HP, plus the other parts above.

This table covers the mounts that hold the engine to the chassis. Typical signs include a clunk on takeoff, a vibration at idle, or a separated rubber insert. Support the powertrain before unbolting a mount, and torque the fasteners in the notes. Read more

9 Motor Mount parts for the 1991 Eagle Talon come from 4 brands — DEA / MARMON RIDE CONTROL, WESTAR, ANCHOR and 1 other brand. The "Popular" part is DEA / MARMON RIDE CONTROL A6142.

Listed part numbers: DEA / MARMON RIDE CONTROL A6142, WESTAR EM8103 and ANCHOR 8103, plus the other parts above.

This table covers the Motor Mount bushings. Typical signs include a clunk over bumps, or a torn or walked-out bushing you can see. Press the new bushing square. A cocked bushing will tear in a few thousand miles. Read more

This group shows a single part: DEA / MARMON RIDE CONTROL A6142in.

This table covers the engine oils listed by grade and specification for this engine. Typical signs include a low-oil lamp, knocking after a long interval, or oil that has gone thin and black well before the next service. Match the viscosity and spec in the notes (and on the filler cap). The tables group grades — they are not interchangeable. Read more

26 Oil parts for the 1991 Eagle Talon come from 2 brands — MOBIL and VALVOLINE. The "Popular" part is MOBIL 125195. Grades run from Conventional through Synthetic Blend; High Mileage (>75,000 Miles) is the most populated section, led by MOBIL and VALVOLINE.

This table covers the Oil Cooler Mounting kits. Read more

HAYDEN supplies both parts for the 1991 Eagle Talon.

Part numbers include HAYDEN 238 and HAYDEN 153.

This table covers the drain plugs in the oil pan. Read more

6 Oil Drain Plug parts for the 1991 Eagle Talon come from 4 brands — DORMAN, AGS, BECK/ARNLEY and 1 other brand. The "Popular" part is AGS ODP00007.

Listed part numbers: AGS ODP00007, DORMAN 090053 and BECK/ARNLEY 0160088, plus the other parts above.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

4 Oil Drain Plug Gasket parts are listed for the 1991 Eagle Talon, from AJUSA, APEX, DORMAN and 1 other brand.

Listed part numbers: AJUSA 22008900, APEX ADP1906 and DORMAN 095141, plus the other parts above.

This table covers the caps on the oil filler neck. Read more

2 Oil Filler Cap parts for the 1991 Eagle Talon come from 2 brands — ACDELCO and MOTORAD.

This group includes ACDELCO 12C36 and MOTORAD MO88.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

13 Oil Filter parts for the 1991 Eagle Talon come from 11 brands — FAMOUS BRAND, FRAM, CHAMP / LUBER-FINER and 8 other brands. The "Popular" part is BOSCH 3421.

The Economy section: 8 options from FAMOUS BRAND, CHAMP / LUBER-FINER, FRAM and 4 other brands. CHAMP / LUBER-FINER PH2856A is listed in this group.

Standard Replacement: 5 parts, from BOSCH, DENSO, FRAM and 2 other brands. A representative part number is BOSCH 3421.

This table covers the Oil Level sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

This group shows a single part: WELLS 1S6556.

This table covers the oil pans that hold the engine's oil sump. Read more

3 Oil Pan parts are listed for the 1991 Eagle Talon, from ATP, PIONEER and SPECTRA PREMIUM.

This group includes ATP 103283, PIONEER 501020 and SPECTRA PREMIUM CRP14A.

This table covers the gaskets between the oil pan and the block. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

5 Oil Pan Gasket parts for the 1991 Eagle Talon come from 5 brands — VICTOR REINZ, AJUSA, APEX and 2 other brands. The "Popular" part is VICTOR REINZ 703141410.

This group includes VICTOR REINZ 703141410, AJUSA 14038100 and APEX AOP203 and the remaining parts above.

This table covers the Oil pumps. Typical signs include noise from the pump, no pressure, or fluid that never arrives at the outlet. Prime or fill the pump as the notes require. A dry start is a common way to kill a new unit. Read more

This group shows a single part: TOPLINE OPMI6.

This table covers the gaskets that seal the Oil Pump. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 1991 Eagle Talon — BECK/ARNLEY 0398016.

This table covers the wear sleeves used to restore a Oil Pump seal surface. Read more

3 Oil Pump Repair Sleeve parts are listed for the 1991 Eagle Talon, from SKF, TIMKEN and WJB / INMOTION PARTS.

Part numbers include SKF 99078, TIMKEN KWK99078 and WJB / INMOTION PARTS WS99078.

This table covers the seals at the Oil Pump. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

6 Oil Pump Seal parts are listed for the 1991 Eagle Talon, from NATIONAL, TIMKEN, BCA and 3 other brands. NATIONAL 222025 carries the "Popular" badge.

Listed part numbers: NATIONAL 222025 and BCA NS222025, plus the other parts above.

This table covers the pistons that travel in each cylinder. Typical signs include knock, blow-by, or a cylinder that will not hold compression. Piston work is a short-block job. Match bore, pin and ring pack in the notes — not the photo. Read more

4 Piston parts are listed for the 1991 Eagle Talon, from SILV-O-LITE, ENGINETECH, ITM ENGINE COMPONENTS and 1 other brand.

The Premium section lists 1 option from SILV-O-LITE — a step above OE specification in materials, tolerances or warranty terms. SILV-O-LITE 9123H is listed in this group.

The Standard Replacement section: 3 options from ENGINETECH, ITM ENGINE COMPONENTS and TOPLINE. ENGINETECH K45464P is listed in this group.

Listed part numbers: SILV-O-LITE 9123H, ENGINETECH K45464P and ITM ENGINE COMPONENTS RY6312, plus the other parts above.