2014 Fiat 500 Engine Parts

This table covers the camshafts that open the valves. Read more

MOPAR supplies both parts for the 2014 Fiat 500.

Part numbers include MOPAR 4892639AB and MOPAR 4892929AA.

This table covers the Camshaft Dowel pins. Read more

One part is listed for the 2014 Fiat 500 — MOPAR 4892745AB.

This table covers the seals at each camshaft end. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

8 Camshaft Seal parts for the 2014 Fiat 500 come from 7 brands — ELRING, CONTINENTAL, MOPAR and 4 other brands. The "Popular" part is CONTINENTAL CS9062.

This group includes CONTINENTAL CS9062, ELRING 290710 and MOPAR 4892648AC and the remaining parts above.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

4 Conversion / Lower Gasket Set parts are listed for the 2014 Fiat 500, from AJUSA and ELRING.

This group includes AJUSA 54236600, AJUSA 54328900 and ELRING 928790 and the remaining parts above.

This table covers the main bearings that support the crankshaft in the block. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

6 Crankshaft Main Bearing parts for the 2014 Fiat 500 come from MOPAR. The "Popular" part is MOPAR 4892798AA.

Part numbers include MOPAR 4892798AA, MOPAR 4892796AA and MOPAR 4892757AA, among others listed above.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

11 Crankshaft Seal parts for the 2014 Fiat 500 come from 6 brands — AJUSA, ELRING, SKF and 3 other brands. The "Popular" part is ELRING 069540.

This table covers the Cylinder Head Alignment Dowel pins. Read more

MOPAR supplies the 4 Cylinder Head Alignment Dowel Pin parts for the 2014 Fiat 500.

Listed part numbers: MOPAR 68285334AA, MOPAR 4892745AB and MOPAR 6509657AA, plus the other parts above.

This table covers the bolts that clamp the cylinder head to the block. Read more

4 Cylinder Head Bolt parts are listed for the 2014 Fiat 500, from ELRING, AJUSA and VICTOR REINZ.

Listed part numbers: AJUSA 81025400, ELRING 111590 and ELRING 760720, plus the other parts above.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

11 Cylinder Head Gasket parts are listed for the 2014 Fiat 500, from ELRING, MOPAR, AJUSA and 1 other brand. ELRING 344671 carries the "Popular" badge.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

4 Cylinder Head Gasket Set parts are listed for the 2014 Fiat 500, from AJUSA, ELRING and SKP.

This group includes AJUSA 52455400, AJUSA 52439800 and ELRING 431590 and the remaining parts above.

This table covers the block heaters that warm the coolant or oil in cold weather. Read more

2 Engine Block Heater parts for the 2014 Fiat 500 come from 2 brands — KAT'S HEATERS and MOPAR.

This group includes KAT'S HEATERS 11487 and MOPAR 68079689AA.

This table covers the Engine covers. Read more

MOPAR supplies both parts for the 2014 Fiat 500.

Part numbers include MOPAR 68073805AC and MOPAR 68081716AC.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

AJUSA supplies both parts for the 2014 Fiat 500.

This group includes AJUSA 50415400 and AJUSA 50564200.

This table covers the exhaust valves that let combustion gas out of the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

3 Exhaust Valve parts for the 2014 Fiat 500 come from 2 brands — MOPAR and SBI.

Part numbers include MOPAR 4892677AB, MOPAR 4892925AB and SBI 13478S.

This table covers the Expansion plugs. Typical signs include a leak at the drain or glow-plug hole, or a plug that has rounded off. Replace the crush washer and torque to the spec in the notes. Read more

One part is listed for the 2014 Fiat 500 — MOPAR 6509803AA.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

6 Intake Manifold Gasket parts are listed for the 2014 Fiat 500, from AJUSA, MOPAR, ELRING and 1 other brand.

Listed part numbers: AJUSA 13214700, AJUSA 13268500 and ELRING 444760, plus the other parts above.

This table covers the gaskets that seal the Intake Plenum. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Intake Plenum Gasket parts for the 2014 Fiat 500 come from ELRING.

Part numbers include ELRING 689940 and ELRING 926370.

This table covers the intake valves that let air (and fuel, on port-injected engines) into the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

2 Intake Valve parts for the 2014 Fiat 500 come from 2 brands — MOPAR and SBI.

Part numbers include MOPAR 4892676AB and SBI 13477.

This table covers the mounts that hold the engine to the chassis. Typical signs include a clunk on takeoff, a vibration at idle, or a separated rubber insert. Support the powertrain before unbolting a mount, and torque the fasteners in the notes. Read more

6 Motor Mount parts for the 2014 Fiat 500 come from 4 brands — DEA / MARMON RIDE CONTROL, MOPAR, ANCHOR and 1 other brand. The "Popular" part is DEA / MARMON RIDE CONTROL A5761.

Part numbers include DEA / MARMON RIDE CONTROL A5761, ANCHOR 9893 and DEA / MARMON RIDE CONTROL A5639, among others listed above.

This table covers the brackets that mount the Motor Mount. Typical signs include a cracked mount, a rattle, or a bracket that no longer holds alignment. Confirm position in the notes. Many brackets look alike and bolt to different corners. Read more

7 Motor Mount Bracket parts for the 2014 Fiat 500 come from MOPAR. The "Popular" part is MOPAR 68073107AC.

Part numbers include MOPAR 68073107AC, MOPAR 4892873AB and MOPAR 4892874AB, among others listed above.

This table covers the isolators in an engine mount. Read more

MOPAR supplies the 3 Motor Mount Isolator parts for the 2014 Fiat 500.

This group includes MOPAR 68073029AC, MOPAR 68081614AD and MOPAR 68105215AB.

This table covers the engine oils listed by grade and specification for this engine. Typical signs include a low-oil lamp, knocking after a long interval, or oil that has gone thin and black well before the next service. Match the viscosity and spec in the notes (and on the filler cap). The tables group grades — they are not interchangeable. Read more

31 Oil parts for the 2014 Fiat 500 come from 6 brands — VALVOLINE, MOBIL, LIQUI MOLY and 3 other brands. The "Popular" part is LIQUI MOLY 20228. Full Synthetic, High Mileage (>75,000 Miles) and Synthetic Blend are all represented, and Full Synthetic alone accounts for 20 parts.

This table covers the heat exchangers that cool engine oil. Typical signs include oil at the cooler fittings, or coolant that looks like a milkshake. Pressure-test both circuits after a cooler swap — a leak here mixes oil and coolant. Read more

This group shows a single part: NISSENS 90969.

This table covers the gaskets that seal the Oil Cooler. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Oil Cooler Gasket parts are listed for the 2014 Fiat 500, from AJUSA and MOPAR.

This group includes AJUSA 77016000 and MOPAR 68213432AA.

This table covers the Oil Cooler Hose pipes. Read more

This group shows a single part: MOPAR 68073482AA.

This table covers the Oil Dipstick tubes. Read more

6 Oil Dipstick / Tube parts for the 2014 Fiat 500 come from MOPAR.

Part numbers include MOPAR 4892700AA, MOPAR 4892701AC and MOPAR 4892836AD, among others listed above.

This table covers the drain plugs in the oil pan. Read more

7 Oil Drain Plug parts for the 2014 Fiat 500 come from 5 brands — DORMAN, AGS, ELRING and 2 other brands. The "Popular" part is AGS ODP00007.

Listed part numbers: AGS ODP00007, DORMAN 090053 and DORMAN 090115, plus the other parts above.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Oil Drain Plug Gasket parts are listed for the 2014 Fiat 500, from AJUSA and ELRING.

Part numbers include AJUSA 01707600 and ELRING 110604.

This table covers the caps on the oil filler neck. Read more

3 Oil Filler Cap parts for the 2014 Fiat 500 come from 2 brands — MOPAR and MOTORAD.

This group includes MOPAR 4892822AB, MOPAR 4892928AA and MOTORAD MO221.

This table covers the Oil Filler tubes. Read more

2 Oil Filler Tube parts for the 2014 Fiat 500 come from MOPAR.

This group includes MOPAR 68081719AC and MOPAR 68153342AA.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

17 Oil Filter parts for the 2014 Fiat 500 come from 17 brands — PRO-TEC, CHAMP / LUBER-FINER, CHAMPION FILTER and 14 other brands. The "Popular" part is PRO-TEC PXL57341.

The Economy section lists 7 options from PRO-TEC, CHAMP / LUBER-FINER, CHAMPION FILTER and 4 other brands — the catalog's value-priced group. PRO-TEC PXL57341 is listed in this group.

In the Standard Replacement grade, ACDELCO, MANN, WIX and 7 other brands supply 10 parts: built to original-equipment specification. A representative part number is ACDELCO PF607G.

This table covers the Oil Filter adapters. Read more

MOPAR supplies both parts for the 2014 Fiat 500.

This group includes MOPAR 4892638AB and MOPAR 4892932AB.

This table covers the Oil Filter Adapter Gasket O-rings. Typical signs include a seep at a fitting or a housing that weeps after a service. Lube the new O-ring with the fluid it will see, and do not roll it into the groove. Read more

2 Oil Filter Adapter Gasket / O-Ring parts are listed for the 2014 Fiat 500, from ELRING and MOPAR.

This group includes ELRING 944180 and MOPAR 4892856AA.

This table covers the Oil Filter covers. Read more

4 Oil Filter Cover parts are listed for the 2014 Fiat 500, from DORMAN, MOPAR, MOTORAD and 1 other brand.

Part numbers include DORMAN 921160, MOPAR 4892850AA and MOTORAD MO317, among others listed above.

This table covers the oil pans that hold the engine's oil sump. Read more

MOPAR supplies both parts for the 2014 Fiat 500.

Part numbers include MOPAR 4892751AG and MOPAR 4892916AD.

This table covers the gaskets between the oil pan and the block. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

This group shows a single part: VICTOR REINZ 703141410.

This table covers the Oil pumps. Typical signs include noise from the pump, no pressure, or fluid that never arrives at the outlet. Prime or fill the pump as the notes require. A dry start is a common way to kill a new unit. Read more

2 Oil Pump parts for the 2014 Fiat 500 come from 2 brands — MELLING and MOPAR.

This group includes MELLING M527 and MOPAR 5047363AB.

This table covers the gaskets that seal the Oil Pump. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Oil Pump Gasket parts are listed for the 2014 Fiat 500, from ELRING and MOPAR.

Part numbers include ELRING 725830 and MOPAR 68145326AA.

This table covers the pickup tubes and screens that feed the oil pump. Read more

One part is listed for the 2014 Fiat 500 — MOPAR 68145352AA.

This table covers the Oil Temperature senders. Read more

3 Oil Temperature Sender parts are listed for the 2014 Fiat 500, from MOPAR and VEMO.

This group includes MOPAR 68070744AB, MOPAR 68088241AA and VEMO V33720253.

This table covers the pistons that travel in each cylinder. Typical signs include knock, blow-by, or a cylinder that will not hold compression. Piston work is a short-block job. Match bore, pin and ring pack in the notes — not the photo. Read more

MOPAR supplies both parts for the 2014 Fiat 500.

This group includes MOPAR 68104675AA and MOPAR 68104676AA.

This table covers the rings that seal each piston to the cylinder wall. Read more

6 Piston Ring parts are listed for the 2014 Fiat 500, from HASTINGS MANUFACTURING, MAHLE / CLEVITE and MOPAR. HASTINGS MANUFACTURING 2C5266 carries the "Popular" badge.

The Premium section lists 1 option from MAHLE / CLEVITE — a step above OE specification in materials, tolerances or warranty terms. MAHLE / CLEVITE 42424 is listed in this group.

The Standard Replacement section: 5 options from HASTINGS MANUFACTURING and MOPAR. HASTINGS MANUFACTURING 2C5266 is listed in this group.

This group includes HASTINGS MANUFACTURING 2C5266, MAHLE / CLEVITE 42424 and HASTINGS MANUFACTURING 2C5681 and the remaining parts above.

This table covers the rocker arms that transfer cam motion to the valves. Read more

This group shows a single part: INA VF0130.