2004 MG TF Engine Parts

This table covers the seals at each camshaft end. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

2 Camshaft Seal parts for the 2004 MG TF come from AJUSA.

Listed part numbers: AJUSA 15008100 and AJUSA 15056300.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

One part is listed for the 2004 MG TF — AJUSA 54078900.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

4 Crankshaft Seal parts for the 2004 MG TF come from 2 brands — AJUSA and VICTOR REINZ.

Part numbers include AJUSA 15045300, AJUSA 15045400 and VICTOR REINZ 813484200, among others listed above.

This table covers the bolts that clamp the cylinder head to the block. Read more

One part is listed for the 2004 MG TF — AJUSA 81026400.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Cylinder Head Gasket parts are listed for the 2004 MG TF, from AJUSA and ELRING.

Listed part numbers: AJUSA 10071400 and ELRING 167411.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

3 Cylinder Head Gasket Set parts are listed for the 2004 MG TF, from AJUSA and ELRING.

Listed part numbers: AJUSA 52138200, AJUSA 52172300 and ELRING 167381.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

AJUSA supplies both parts for the 2004 MG TF.

This group includes AJUSA 50151300 and AJUSA 50186200.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

AJUSA supplies both parts for the 2004 MG TF.

Listed part numbers: AJUSA 13120100 and AJUSA 13120300.

This table covers the gaskets that seal the Intake Plenum. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

This group shows a single part: AJUSA 00753300.

This table covers the engine oils listed by grade and specification for this engine. Typical signs include a low-oil lamp, knocking after a long interval, or oil that has gone thin and black well before the next service. Match the viscosity and spec in the notes (and on the filler cap). The tables group grades — they are not interchangeable. Read more

6 Oil parts for the 2004 MG TF come from VALVOLINE. The "Popular" part is VALVOLINE VV966.

The Full Synthetic section lists 3 options from VALVOLINE — full-synthetic oils. VALVOLINE VV966 is listed in this group.

In the High Mileage (>75,000 Miles) grade, VALVOLINE supplies 3 parts: oils grouped for high-mileage engines. A representative part number is VALVOLINE VV179.

Listed part numbers: VALVOLINE VV966, VALVOLINE 881166 and VALVOLINE 881050, plus the other parts above.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2004 MG TF — AJUSA 22007400.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

3 Oil Filter parts for the 2004 MG TF come from 3 brands — VARIOUS MFR, HENGST and MAHLE / CLEVITE.

The Economy section lists 1 option from VARIOUS MFR — the catalog's value-priced group. VARIOUS MFR PG7819 is listed in this group.

In the Standard Replacement grade, HENGST and MAHLE / CLEVITE supply 2 parts: built to original-equipment specification. A representative part number is HENGST H90W29.

Listed part numbers: VARIOUS MFR PG7819, HENGST H90W29 and MAHLE / CLEVITE OC2371.

This table covers the gaskets that seal the valve cover to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

This group shows a single part: AJUSA 11064700.

This table covers the lifters / tappets that transfer cam motion to the valves. Read more

This group shows a single part: AJUSA 85014200.