2005 Peugeot Partner Cooling System Parts

This table covers the engine coolants and antifreeze formulations specified for this cooling system. Typical signs include a rising temperature gauge, rusty or sludged coolant, or a heater that blows cold. Use the chemistry named in the notes. Mixing silicate, OAT and HOAT formulas can gel in the radiator. Read more

12 Coolant / Antifreeze parts for the 2005 Peugeot Partner come from 4 brands — PRESTONE, PEAK, VALVOLINE and 1 other brand. The "Popular" part is FVP MV5050GAL.

In the Compatible With All Colors grade, PRESTONE supplies 1 part: grouped under the catalog's "Compatible With All Colors" designation — the notes column spells out what sets them apart. A representative part number is PRESTONE AF3055.

The Economy section lists 4 options from FVP, PEAK, PRESTONE and 1 other brand — the catalog's value-priced group. FVP MV5050GAL is listed in this group.

In the Heavy Duty grade, PRESTONE supplies 1 part: rated for severe service. A representative part number is PRESTONE AFC12100.

In the Premium grade, PRESTONE and PEAK supply 4 parts: a step above OE specification in materials, tolerances or warranty terms. A representative part number is PRESTONE AF2100.

In the Standard Replacement grade, VALVOLINE and PEAK supply 2 parts: built to original-equipment specification. A representative part number is VALVOLINE ZXEL1.

This table covers the radiators that dump engine heat to airflow through the core. Typical signs include overheating in traffic, a wet core, or coolant that disappears with no puddle. Replace the cap if it cannot hold the rated pressure, and bleed the system after the swap. Read more

2 Radiator parts for the 2005 Peugeot Partner come from NISSENS.

Listed part numbers: NISSENS 63502 and NISSENS 63716.

This table covers the fan assemblies (and clutches, where listed) that pull air through the radiator. Read more

One part is listed for the 2005 Peugeot Partner — NISSENS 85674.

This table covers the senders that report coolant temperature to the gauge or ECU. Typical signs include a gauge that sits on empty or overheat, or a lamp that does not match what the engine is doing. Rule out the cluster and the wiring before replacing the sender. Read more

3 Temperature Sender / Sensor parts for the 2005 Peugeot Partner come from 3 brands — GPD, STANDARD MOTOR PRODUCTS and MARELLI.

The Economy section: 1 option from GPD. GPD 1814506 is listed in this group.

Standard Replacement: 1 part, from STANDARD MOTOR PRODUCTS. A representative part number is STANDARD MOTOR PRODUCTS TX241.

1 further part sits outside the graded sections, with the same engine-level match.

Part numbers include GPD 1814506, STANDARD MOTOR PRODUCTS TX241 and MARELLI SPA161.

This table covers the thermostats that open the coolant circuit at the specified temperature. Typical signs include slow warm-up, a gauge that climbs in traffic, or heat that never quite arrives. Replace the housing gasket with the thermostat and bleed the system so a trapped air pocket does not cook the new part. Read more

2 Thermostat parts are listed for the 2005 Peugeot Partner, from MOTORAD and STANT.

Part numbers include MOTORAD 438192 and STANT 49849.

This table covers the seals at the thermostat housing and water outlet. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

This group shows a single part: VICTOR REINZ 711555100.

This table covers the housings and outlets the thermostat sits in. Read more

2 Thermostat Housing / Water Outlet parts are listed for the 2005 Peugeot Partner, from DORMAN and MOTORAD.

Economy: 1 part, from DORMAN. A representative part number is DORMAN 902748.

The Standard Replacement section: 1 option from MOTORAD. MOTORAD CH2748 is listed in this group.

Listed part numbers: DORMAN 902748 and MOTORAD CH2748.

This table covers the pumps that circulate coolant through the block and radiator. Typical signs include coolant at the weep hole, pulley play, or a growl from the front of the engine. Replace the thermostat and refill with the specified coolant whenever the pump comes off. Read more

5 Water Pump parts are listed for the 2005 Peugeot Partner, from FVP, US MOTOR WORKS, WJB / INMOTION PARTS and 1 other brand. US MOTOR WORKS US8937 carries the "Popular" badge.

Economy: 3 parts, from US MOTOR WORKS, FVP and WJB / INMOTION PARTS. A representative part number is US MOTOR WORKS US8937.

The Standard Replacement section: 2 options from FVP and GMB. FVP 1569002 is listed in this group.

Listed part numbers: US MOTOR WORKS US8937 and WJB / INMOTION PARTS WU8937, plus the other parts above.