2010 Peugeot Partner Engine Parts

This table covers the camshafts that open the valves. Read more

AJUSA supplies both parts for the 2010 Peugeot Partner.

Part numbers include AJUSA 93123500 and AJUSA 93123600.

This table covers the seals at each camshaft end. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

3 Camshaft Seal parts for the 2010 Peugeot Partner come from 2 brands — AJUSA and ELRING.

Part numbers include AJUSA 15091700, AJUSA 15083800 and ELRING 026740.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

3 Conversion / Lower Gasket Set parts are listed for the 2010 Peugeot Partner, from AJUSA and ELRING.

Part numbers include AJUSA 54216100, AJUSA 54212500 and ELRING 030780.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

7 Crankshaft Seal parts for the 2010 Peugeot Partner come from 3 brands — AJUSA, ELRING and VICTOR REINZ. The "Popular" part is ELRING 026790. 1 part fits every engine; the other 6 are engine-specific.

Listed part numbers: ELRING 026790, AJUSA 15094100 and AJUSA 15094200, plus the other parts above.

This table covers the bolts that clamp the cylinder head to the block. Read more

3 Cylinder Head Bolt parts are listed for the 2010 Peugeot Partner, from AJUSA and ELRING.

This group includes AJUSA 81044200, AJUSA 81034200 and ELRING 330390.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

6 Cylinder Head Gasket parts are listed for the 2010 Peugeot Partner, from ELRING and AJUSA. ELRING 569802 carries the "Popular" badge.

This group includes ELRING 569802, AJUSA 10155800 and ELRING 569812 and the remaining parts above.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

AJUSA supplies both parts for the 2010 Peugeot Partner.

This group includes AJUSA 52451100 and AJUSA 53064400.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

4 Engine Kit Gasket Set parts are listed for the 2010 Peugeot Partner, from AJUSA and ELRING.

This group includes AJUSA 50291900, AJUSA 51068900 and ELRING 726090 and the remaining parts above.

This table covers the exhaust valves that let combustion gas out of the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

This group shows a single part: QUALCAST 1030127.

This table covers the crankshaft pulleys / harmonic balancers at the front of the engine. Read more

One part is listed for the 2010 Peugeot Partner — DORMAN 594487.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

4 Intake Manifold Gasket parts are listed for the 2010 Peugeot Partner, from AJUSA and ELRING.

This group includes AJUSA 01158800, AJUSA 77015200 and ELRING 389041 and the remaining parts above.

This table covers the gaskets that seal the Intake Plenum. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

4 Intake Plenum Gasket parts for the 2010 Peugeot Partner come from 2 brands — AJUSA and ELRING.

Listed part numbers: AJUSA 24023100, AJUSA 16072400 and AJUSA 16072500, plus the other parts above.

This table covers the intake valves that let air (and fuel, on port-injected engines) into the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

This group shows a single part: QUALCAST 1030126.

This table covers the engine oils listed by grade and specification for this engine. Typical signs include a low-oil lamp, knocking after a long interval, or oil that has gone thin and black well before the next service. Match the viscosity and spec in the notes (and on the filler cap). The tables group grades — they are not interchangeable. Read more

3 Oil parts for the 2010 Peugeot Partner come from VALVOLINE. Every part fits both the 1.6L L4 and the 1.6L L4 DIESEL Turbocharged.

Listed part numbers: VALVOLINE VV966, VALVOLINE 881166 and VALVOLINE 881050.

This table covers the heat exchangers that cool engine oil. Typical signs include oil at the cooler fittings, or coolant that looks like a milkshake. Pressure-test both circuits after a cooler swap — a leak here mixes oil and coolant. Read more

This group shows a single part: PIERBURG 709269300.

This table covers the gaskets that seal the Oil Cooler. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2010 Peugeot Partner — ELRING 027170.

This table covers the drain plugs in the oil pan. Read more

2 Oil Drain Plug parts for the 2010 Peugeot Partner come from ELRING.

This group includes ELRING 877930 and ELRING 587220.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

3 Oil Drain Plug Gasket parts are listed for the 2010 Peugeot Partner, from AJUSA and ELRING.

This group includes AJUSA 20003300, AJUSA 21008600 and ELRING 108502.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

6 Oil Filter parts for the 2010 Peugeot Partner come from 4 brands — MANN, WIX, VARIOUS MFR and 1 other brand.

The Economy section lists 1 option from VARIOUS MFR — the catalog's value-priced group. VARIOUS MFR PG9093 is listed in this group.

In the Standard Replacement grade, MANN and WIX supply 2 parts: built to original-equipment specification. A representative part number is MANN HU7162X.

3 further parts sit outside the graded sections, with the same engine-level match.

Part numbers include VARIOUS MFR PG9093, MANN HU7162X and WIX WL7305, among others listed above.

This table covers the rings that seal each piston to the cylinder wall. Read more

5 Piston Ring parts are listed for the 2010 Peugeot Partner, from HASTINGS MANUFACTURING and MAHLE / CLEVITE. 1 part fits every engine; the other 4 are engine-specific.

The Premium section lists 1 option from MAHLE / CLEVITE — a step above OE specification in materials, tolerances or warranty terms. MAHLE / CLEVITE 42238CP is listed in this group.

The Standard Replacement section: 4 options from HASTINGS MANUFACTURING. HASTINGS MANUFACTURING 2C9369S is listed in this group.

Part numbers include MAHLE / CLEVITE 42238CP, HASTINGS MANUFACTURING 2C9369S and HASTINGS MANUFACTURING 2C9369, among others listed above.

This table covers the Timing Belt tensioners. Typical signs include belt flutter, a chirp that returns after a new belt, or an arm that no longer damps. Replace the tensioner with the belt at higher mileage. Read more

This group shows a single part: GMB 4565713.

This table covers kits that group a timing chain with the related tensioners and guides. Read more

This group shows a single part: INA ZC0106K.

This table covers the tensioners that keep the timing chain taut. Typical signs include belt flutter, a chirp that returns after a new belt, or an arm that no longer damps. Replace the tensioner with the belt at higher mileage. Read more

This group shows a single part: INA ZT0060.

This table covers the gaskets that seal the Turbocharger. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2010 Peugeot Partner — AJUSA JTC12014.

This table covers the fasteners that mount the turbocharger. Read more

3 Turbocharger Mounting Hardware parts are listed for the 2010 Peugeot Partner, from ELRING and AJUSA. 1 part fits every engine; the other 2 are engine-specific.

This group includes AJUSA OPK00010, ELRING 584560 and ELRING 714600.

This table covers the Turbocharger Oil lines. Typical signs include a wet fitting, a rusted pipe, or a pressure loss in this circuit. Flare or thread the new line the way the notes specify; a kinked replacement will fail early. Read more

5 Turbocharger Oil Line parts for the 2010 Peugeot Partner come from AJUSA.

This group includes AJUSA OP10049, AJUSA OPR00007 and AJUSA OPR00008 and the remaining parts above.

This table covers the Valve covers. Read more

One part is listed for the 2010 Peugeot Partner — ELRING 052730.

This table covers the gaskets that seal the valve cover to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

3 Valve Cover Gasket parts for the 2010 Peugeot Partner come from 2 brands — AJUSA and ELRING.

This group includes AJUSA 11117200, AJUSA 11097900 and ELRING 375510.

This table covers the lifters / tappets that transfer cam motion to the valves. Read more

2 Valve Lifter parts for the 2010 Peugeot Partner come from 2 brands — AJUSA and INA.

Listed part numbers: AJUSA 85014300 and INA VT0086.

This table covers the seals on each valve stem that control oil into the guides. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

4 Valve Stem Seal parts for the 2010 Peugeot Partner come from 2 brands — AJUSA and ELRING.

Listed part numbers: AJUSA 57023600, AJUSA 12022400 and AJUSA 57043000, plus the other parts above.