2011 Ram 4000 Engine Parts

This table covers the Barometric pressure sensors. Typical signs include a check-engine light for MAP or fuel-rail pressure, or a limp mode under load. A vacuum leak or a clogged reference line will fake a bad pressure sensor. Read more

One part is listed for the 2011 Ram 4000 — HOLSTEIN 2MAP0143.

This table covers the bearings in the connecting-rod big ends. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

KING ENGINE BEARINGS supplies both parts for the 2011 Ram 4000.

Listed part numbers: KING ENGINE BEARINGS CR1305SI and KING ENGINE BEARINGS CR1305CA.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

One part is listed for the 2011 Ram 4000 — AJUSA 54325700.

This table covers the main bearings that support the crankshaft in the block. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

This group shows a single part: KING ENGINE BEARINGS MB7009SI.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

3 Crankshaft Seal parts for the 2011 Ram 4000 come from 2 brands — AJUSA and DORMAN.

Part numbers include AJUSA 15112400, AJUSA 15125700 and DORMAN 635450.

This table covers the gaskets that seal the Crankshaft Seal. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2011 Ram 4000 — ELRING 049640.

This table covers the cylinder heads that close the top of the block. Read more

This group shows a single part: CYLINDER HEAD EXPRESS CH6707N.

This table covers the bolts that clamp the cylinder head to the block. Read more

One part is listed for the 2011 Ram 4000 — AJUSA 81084000.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Cylinder Head Gasket parts are listed for the 2011 Ram 4000, from AJUSA and ELRING.

This group includes AJUSA 10216900 and ELRING 049830.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

3 Cylinder Head Gasket Set parts are listed for the 2011 Ram 4000, from ELRING and AJUSA.

Part numbers include AJUSA 52624600, ELRING 746560 and ELRING 093950.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

One part is listed for the 2011 Ram 4000 — AJUSA 50557200.

This table covers the crankshaft pulleys / harmonic balancers at the front of the engine. Read more

2 Harmonic Balancer parts are listed for the 2011 Ram 4000, from ATP and DORMAN.

This group includes ATP 102491 and DORMAN 594818.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

5 Intake Manifold Gasket parts are listed for the 2011 Ram 4000, from ELRING and AJUSA. ELRING 049780 carries the "Popular" badge.

This group includes ELRING 049780, AJUSA 13244400 and ELRING 165710 and the remaining parts above.

This table covers the intake valves that let air (and fuel, on port-injected engines) into the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

This group shows a single part: ENGINE PRO 01499012.

This table covers the mounts that hold the engine to the chassis. Typical signs include a clunk on takeoff, a vibration at idle, or a separated rubber insert. Support the powertrain before unbolting a mount, and torque the fasteners in the notes. Read more

5 Motor Mount parts for the 2011 Ram 4000 come from 3 brands — WESTAR, DEA / MARMON RIDE CONTROL and SKP. The "Popular" part is WESTAR EM4091.

The Economy section lists 1 option from SKP — the catalog's value-priced group. SKP SKM3409 is listed in this group.

In the Standard Replacement grade, WESTAR and DEA / MARMON RIDE CONTROL supply 4 parts: built to original-equipment specification. A representative part number is WESTAR EM4091.

Part numbers include WESTAR EM4091, SKP SKM3409 and DEA / MARMON RIDE CONTROL AM044, among others listed above.

This table covers the Motor Mount bushings. Typical signs include a clunk over bumps, or a torn or walked-out bushing you can see. Press the new bushing square. A cocked bushing will tear in a few thousand miles. Read more

This group shows a single part: DEA / MARMON RIDE CONTROL AM043.

This table covers the heat exchangers that cool engine oil. Typical signs include oil at the cooler fittings, or coolant that looks like a milkshake. Pressure-test both circuits after a cooler swap — a leak here mixes oil and coolant. Read more

This group shows a single part: SKP SK918335.

This table covers the gaskets that seal the Oil Cooler. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Oil Cooler Gasket parts are listed for the 2011 Ram 4000, from AJUSA and ELRING.

Listed part numbers: AJUSA 77062600 and ELRING 109210.

This table covers the Oil Cooler Mounting kits. Read more

HAYDEN supplies both parts for the 2011 Ram 4000.

This group includes HAYDEN 238 and HAYDEN 153.

This table covers the Oil Dipstick tubes. Read more

2 Oil Dipstick / Tube parts for the 2011 Ram 4000 come from DORMAN.

Part numbers include DORMAN 921279 and DORMAN 9175509.

This table covers the seals at the Oil Dipstick / Tube. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

One part is listed for the 2011 Ram 4000 — ELRING 097140.

This table covers the drain plugs in the oil pan. Read more

3 Oil Drain Plug parts for the 2011 Ram 4000 come from 3 brands — AGS, DORMAN and ELRING.

This group includes AGS ODP00013, DORMAN 090173 and ELRING 049720.

This table covers the caps on the oil filler neck. Read more

This group shows a single part: MOTORAD MO111.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

2 Oil Filter parts for the 2011 Ram 4000 come from VARIOUS MFR.

The Economy section: 1 option from VARIOUS MFR. VARIOUS MFR PG5335 is listed in this group.

Standard Replacement: 1 part, from VARIOUS MFR. A representative part number is VARIOUS MFR PO5335EX.

Part numbers include VARIOUS MFR PG5335 and VARIOUS MFR PO5335EX.

This table covers the oil pans that hold the engine's oil sump. Read more

3 Oil Pan parts are listed for the 2011 Ram 4000, from DORMAN, SKP and SPECTRA PREMIUM.

Part numbers include DORMAN 264470, SKP SK264470 and SPECTRA PREMIUM CRP45A.

This table covers the gaskets between the oil pan and the block. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

3 Oil Pan Gasket parts for the 2011 Ram 4000 come from 3 brands — AJUSA, ELRING and VICTOR REINZ.

Part numbers include AJUSA 14120000, ELRING 097160 and VICTOR REINZ 101015001.

This table covers the gaskets that seal the Oil Pressure Relief Valve. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

ELRING supplies both parts for the 2011 Ram 4000.

Part numbers include ELRING 094770 and ELRING 109220.

This table covers the gaskets that seal the Oil Pump. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

ELRING supplies both parts for the 2011 Ram 4000.

Part numbers include ELRING 846070 and ELRING 049710.

This table covers the rings that seal each piston to the cylinder wall. Read more

One part is listed for the 2011 Ram 4000 — MAHLE / CLEVITE 42140.

This table covers the gaskets that seal the Timing Chain Cover. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2011 Ram 4000 — ELRING 049900.

This table covers the Timing covers. Read more

DORMAN supplies both parts for the 2011 Ram 4000.

This group includes DORMAN 635180 and DORMAN 635212.

This table covers the gaskets that seal the Timing Cover. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

2 Timing Cover Gasket parts for the 2011 Ram 4000 come from 2 brands — ELRING and VICTOR REINZ.

Listed part numbers: ELRING 049690 and VICTOR REINZ 151023501.

This table covers the Turbocharger Coolant lines. Typical signs include a wet fitting, a rusted pipe, or a pressure loss in this circuit. Flare or thread the new line the way the notes specify; a kinked replacement will fail early. Read more

4 Turbocharger Coolant Line parts for the 2011 Ram 4000 come from 2 brands — DORMAN and GPD.

Part numbers include DORMAN 667502, DORMAN 667501 and DORMAN 667050, among others listed above.