1968 Triumph TR250 Electrical Parts

This table covers the alternators that charge the battery and run the electrical load. Typical signs include dim lights at idle, a battery lamp, or a growl from the charging pulley. Load-test the battery and inspect the belt and grounds — a bad ground mimics a failed alternator. Read more

4 Alternator / Generator parts for the 1968 Triumph TR250 come from 4 brands — FVP, PURE ENERGY, REMY and 1 other brand.

This group includes FVP 14029 and REMY 14013 and the remaining parts above.

This table covers the bearings in the alternator housing. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

3 Alternator / Generator End Bearing parts are listed for the 1968 Triumph TR250, from WJB / INMOTION PARTS, BCA and NATIONAL.

In the Economy grade, WJB / INMOTION PARTS supplies 1 part: the catalog's value-priced group. A representative part number is WJB / INMOTION PARTS RB6202.

The Standard Replacement section lists 1 option from BCA — built to original-equipment specification. BCA NB202 is listed in this group.

1 ungrouped part is not assigned to a grade, with the same engine-level match.

Part numbers include WJB / INMOTION PARTS RB6202, BCA NB202 and NATIONAL 202.

This table covers the batteries listed by group size and specification. Typical signs include slow cranking, a battery lamp, or a no-start after the vehicle sat overnight. Confirm group size and terminal layout in the notes. Clean the posts and the ground before condemning the battery. Read more

3 Battery parts are listed for the 1968 Triumph TR250, from ACDELCO, BOSCH and EXIDE.

This group includes ACDELCO 31AGMA, BOSCH T631P and EXIDE MX24.

This table covers the positive and ground cables that run from the battery. Typical signs include a stretched or frayed cable, or a control that no longer reaches the end of its travel. Route the new cable through the same clips. A kinked cable binds and fails early. Read more

9 Battery Cable parts for the 1968 Triumph TR250 come from 3 brands — DEKA, STANDARD MOTOR PRODUCTS and ACDELCO. The "Popular" part is DEKA 00802.

Part numbers include DEKA 00802, STANDARD MOTOR PRODUCTS 7154C and ACDELCO 4BC16, among others listed above.

This table covers the terminals and clamps that connect cables to the battery posts. Read more

DEKA supplies both parts for the 1968 Triumph TR250.

Part numbers include DEKA 00350 and DEKA 01056.

This table covers the starter drives that engage the flywheel ring gear. Read more

One part is listed for the 1968 Triumph TR250 — WELLS 2K1118.

This table covers the starter motors that crank the engine. Typical signs include no motion, a squeal, or a motor that only runs on one speed. Confirm power, ground and the control module before replacing the motor. Read more

8 Starter Motor parts for the 1968 Triumph TR250 come from 6 brands — PURE ENERGY, TERREPOWER, WAI GLOBAL and 3 other brands. The "Popular" part is PURE ENERGY 16121N.

The New section lists 2 options from PURE ENERGY and WAI GLOBAL — brand-new units rather than rebuilt ones. PURE ENERGY 16121N is listed in this group.

The Remanufactured section lists 6 options from TERREPOWER, ACDELCO, FVP and 2 other brands — factory-rebuilt units with new wear components. ACDELCO 3361233 is listed in this group.

This group includes PURE ENERGY 16121N and ACDELCO 3361233 and the remaining parts above.