2017 Toyota RAV4 Engine Parts

This table covers the bearings in the connecting-rod big ends. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

2 Connecting Rod Bearing parts for the 2017 Toyota RAV4 come from 2 brands — MAHLE / CLEVITE and TOPLINE. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: MAHLE / CLEVITE CB1998A4 and TOPLINE RBTO56.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

8 Conversion / Lower Gasket Set parts for the 2017 Toyota RAV4 come from 6 brands — AJUSA, TOPLINE, FEL-PRO and 3 other brands. The "Popular" part is FEL-PRO CS26562. 4 parts fit every engine; the other 4 are engine-specific.

Part numbers include FEL-PRO CS26562, ITM ENGINE COMPONENTS 0922711 and AJUSA 54185000, among others listed above.

This table covers the main bearings that support the crankshaft in the block. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

4 Crankshaft Main Bearing parts are listed for the 2017 Toyota RAV4, from TOPLINE, KING ENGINE BEARINGS and MAHLE / CLEVITE. All of them fit every engine offered in the 2017 RAV4.

Part numbers include KING ENGINE BEARINGS MB5810SI, MAHLE / CLEVITE MS2376A and TOPLINE TWTO56, among others listed above.

This table covers the sleeves used to restore a grooved crankshaft seal surface. Read more

One part is listed for the 2017 Toyota RAV4 — WJB / INMOTION PARTS WS99347.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

13 Crankshaft Seal parts are listed for the 2017 Toyota RAV4, from VICTOR REINZ, FEL-PRO, AJUSA and 5 other brands. FEL-PRO BS40741 carries the "Popular" badge. All of them fit every engine offered in the 2017 RAV4.

This table covers the bolts that clamp the cylinder head to the block. Read more

7 Cylinder Head Bolt parts for the 2017 Toyota RAV4 come from 7 brands — APEX, FEL-PRO, AJUSA and 4 other brands. The "Popular" part is APEX AHB876. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

This group includes APEX AHB876, FEL-PRO ES722492 and AJUSA 81042100 and the remaining parts above.

This table covers the Cylinder Head Bolt washers. Read more

2 Cylinder Head Bolt Washer parts for the 2017 Toyota RAV4 come from 2 brands — FEL-PRO and MAHLE / CLEVITE. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: FEL-PRO ES72899 and MAHLE / CLEVITE GS33354.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

12 Cylinder Head Gasket parts for the 2017 Toyota RAV4 come from 7 brands — APEX, FEL-PRO, AJUSA and 4 other brands. The "Popular" part is APEX AHG882.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

13 Cylinder Head Gasket Set parts for the 2017 Toyota RAV4 come from 8 brands — FEL-PRO, APEX, VICTOR REINZ and 5 other brands. The "Popular" part is APEX AHS8082.

This table covers the block heaters that warm the coolant or oil in cold weather. Read more

KAT'S HEATERS supplies both parts for the 2017 Toyota RAV4.

This group includes KAT'S HEATERS 11813 and KAT'S HEATERS 28813.

This table covers the Engine covers. Read more

8 Engine Cover parts for the 2017 Toyota RAV4 come from 2 brands — TECHPRO and VARIOUS MFR. The "Popular" part is TECHPRO TO1228188. 4 parts fit every engine; the other 4 are engine-specific.

This group includes TECHPRO TO1228188, TECHPRO LX1228159 and TECHPRO TO1228264 and the remaining parts above.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

4 Engine Kit Gasket Set parts for the 2017 Toyota RAV4 come from 2 brands — AJUSA and TOPLINE. 1 part fits every engine; the other 3 are engine-specific.

This group includes AJUSA 50421100, AJUSA 50405300 and TOPLINE CGSTO56 and the remaining parts above.

This table covers the exhaust valves that let combustion gas out of the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

2 Exhaust Valve parts are listed for the 2017 Toyota RAV4, from MELLING and TOPLINE. All of them fit every engine offered in the 2017 RAV4.

Listed part numbers: MELLING V5812 and TOPLINE EVTO56.

This table covers the crankshaft pulleys / harmonic balancers at the front of the engine. Read more

6 Harmonic Balancer parts for the 2017 Toyota RAV4 come from 6 brands — SKP, ATP, DAYCO and 3 other brands. The "Popular" part is SKP SK594403. 3 parts fit every engine; the other 3 are engine-specific.

The Economy section lists 1 option from SKP — the catalog's value-priced group. SKP SK594403 is listed in this group.

In the Standard Replacement grade, ATP, DAYCO, DORMAN and 1 other brand supply 4 parts: built to original-equipment specification. A representative part number is ATP 102346.

1 further part sits outside the graded sections, with the same engine-level match.

This group includes SKP SK594403, ATP 102346 and DAYCO PB1719N and the remaining parts above.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

9 Intake Manifold Gasket parts for the 2017 Toyota RAV4 come from 6 brands — FEL-PRO, APEX, MAHLE / CLEVITE and 3 other brands. The "Popular" part is FEL-PRO MS97232. 1 part fits every engine; the other 8 are engine-specific.

This group includes FEL-PRO MS97232, FEL-PRO MS97349 and AJUSA 13254000 and the remaining parts above.

This table covers the Intake Manifold Runner Control Valve solenoids. Typical signs include a harsh or missing shift, or a code for this solenoid circuit. Check resistance and the connector before dropping the pan for a solenoid. Read more

This group shows a single part: STANDARD MOTOR PRODUCTS IMRC15.

This table covers the intake valves that let air (and fuel, on port-injected engines) into the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

2 Intake Valve parts are listed for the 2017 Toyota RAV4, from MELLING and TOPLINE. All of them fit every engine offered in the 2017 RAV4.

This group includes MELLING V5813 and TOPLINE IVTO56.

This table covers the mounts that hold the engine to the chassis. Typical signs include a clunk on takeoff, a vibration at idle, or a separated rubber insert. Support the powertrain before unbolting a mount, and torque the fasteners in the notes. Read more

28 Motor Mount parts are listed for the 2017 Toyota RAV4, from ANCHOR, DEA / MARMON RIDE CONTROL, WESTAR and 3 other brands. SKP SKM9498 carries the "Popular" badge. Grades run from Economy through Standard Replacement; Standard Replacement is the most populated section, led by ANCHOR, DEA / MARMON RIDE CONTROL, WESTAR and 2 other brands.

This table covers the Motor Mount kits. Read more

ANCHOR supplies the 3 Motor Mount Kit parts for the 2017 Toyota RAV4.

This group includes ANCHOR 300222, ANCHOR 300220 and ANCHOR 300196.

This table covers the engine oils listed by grade and specification for this engine. Typical signs include a low-oil lamp, knocking after a long interval, or oil that has gone thin and black well before the next service. Match the viscosity and spec in the notes (and on the filler cap). The tables group grades — they are not interchangeable. Read more

39 Oil parts are listed for the 2017 Toyota RAV4, from VALVOLINE, IDEMITSU, LIQUI MOLY and 3 other brands. LIQUI MOLY 22044 carries the "Popular" badge. Grades run from Full Synthetic through Racing; Full Synthetic is the most populated section, led by IDEMITSU, LIQUI MOLY, VALVOLINE and 3 other brands.

This table covers the heat exchangers that cool engine oil. Typical signs include oil at the cooler fittings, or coolant that looks like a milkshake. Pressure-test both circuits after a cooler swap — a leak here mixes oil and coolant. Read more

One part is listed for the 2017 Toyota RAV4 — NISSENS 91362.

This table covers the Oil Dipstick tubes. Read more

One part is listed for the 2017 Toyota RAV4 — DORMAN 921135.

This table covers the seals at the Oil Dipstick / Tube. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

This group shows a single part: BECK/ARNLEY 0396661.

This table covers the drain plugs in the oil pan. Read more

5 Oil Drain Plug parts are listed for the 2017 Toyota RAV4, from DORMAN, AGS, BECK/ARNLEY and 1 other brand. DORMAN 090038 carries the "Popular" badge. All of them fit every engine offered in the 2017 RAV4.

This group includes DORMAN 090038, AGS ODP00011 and BECK/ARNLEY 0160116 and the remaining parts above.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

5 Oil Drain Plug Gasket parts for the 2017 Toyota RAV4 come from 5 brands — DORMAN, APEX, FEL-PRO and 2 other brands. The "Popular" part is DORMAN 095156. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: DORMAN 095156, APEX ADP1902 and FEL-PRO 70822, plus the other parts above.

This table covers the caps on the oil filler neck. Read more

5 Oil Filler Cap parts are listed for the 2017 Toyota RAV4, from DORMAN, CALORSTAT, GATES and 2 other brands. DORMAN 84111 carries the "Popular" badge. All of them fit every engine offered in the 2017 RAV4.

Part numbers include DORMAN 84111, CALORSTAT OC2312 and GATES 31285, among others listed above.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

17 Oil Filter parts are listed for the 2017 Toyota RAV4, from VARIOUS MFR, WIX, PRO-TEC and 12 other brands. PRO-TEC PXL57047 carries the "Popular" badge. 13 parts fit every engine; the other 4 are engine-specific.

Economy: 6 parts, from PRO-TEC, ULTRA-POWER, BOSCH and 3 other brands. A representative part number is PRO-TEC PXL57047.

In the High Performance / Heavy Duty grade, WIX and MOBIL supply 2 parts: grouped under the catalog's "High Performance / Heavy Duty" designation — the notes column spells out what sets them apart. A representative part number is WIX 57047XP.

The Standard Replacement section: 9 options from ACDELCO, DENSO, WIX and 6 other brands. ACDELCO PF2259 is listed in this group.

This table covers the Oil Filter covers. Read more

6 Oil Filter Cover parts for the 2017 Toyota RAV4 come from 5 brands — MOTORAD, DORMAN, SKP and 2 other brands. The "Popular" part is DORMAN 917016. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

This group includes DORMAN 917016, SKP SK917016 and AUTOTECNICA TY1420831 and the remaining parts above.

This table covers the oil pans that hold the engine's oil sump. Read more

6 Oil Pan parts for the 2017 Toyota RAV4 come from 5 brands — SKP, LILAND GLOBAL, DORMAN and 2 other brands. The "Popular" part is LILAND GLOBAL ITOP34B. 5 parts fit every engine; the other 1 is engine-specific.

Part numbers include LILAND GLOBAL ITOP34B, SKP SKOP407 and DORMAN 264593, among others listed above.

This table covers the gaskets between the oil pan and the block. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

5 Oil Pan Gasket parts are listed for the 2017 Toyota RAV4, from VICTOR REINZ, APEX, FEL-PRO and 1 other brand. VICTOR REINZ 703141410 carries the "Popular" badge. All of them fit every engine offered in the 2017 RAV4.

This group includes VICTOR REINZ 703141410, APEX AOP882 and FEL-PRO OS30842 and the remaining parts above.

This table covers the Oil pumps. Typical signs include noise from the pump, no pressure, or fluid that never arrives at the outlet. Prime or fill the pump as the notes require. A dry start is a common way to kill a new unit. Read more

5 Oil Pump parts are listed for the 2017 Toyota RAV4, from SKP, MELLING, ITM ENGINE COMPONENTS and 2 other brands. MELLING M547 carries the "Popular" badge. All of them fit every engine offered in the 2017 RAV4.

Economy: 1 part, from SKP. A representative part number is SKP SK0V021.

The Standard Replacement section: 3 options from MELLING, ITM ENGINE COMPONENTS and TOPLINE. MELLING M547 is listed in this group.

1 ungrouped part is not assigned to a grade, with the same engine-level match.

Part numbers include MELLING M547, SKP SK0V021 and ITM ENGINE COMPONENTS 85000, among others listed above.

This table covers the pistons that travel in each cylinder. Typical signs include knock, blow-by, or a cylinder that will not hold compression. Piston work is a short-block job. Match bore, pin and ring pack in the notes — not the photo. Read more

4 Piston parts for the 2017 Toyota RAV4 come from 2 brands — TOPLINE and MAHLE / CLEVITE.

In the Premium grade, MAHLE / CLEVITE supplies 1 part: a step above OE specification in materials, tolerances or warranty terms. A representative part number is MAHLE / CLEVITE 2243960.

Standard Replacement: 1 part, from TOPLINE. A representative part number is TOPLINE PATO56.

2 further parts sit outside the graded sections, with the same engine-level match.

Listed part numbers: MAHLE / CLEVITE 2243960 and TOPLINE PATO56, plus the other parts above.

This table covers the Piston Pin bushings. Typical signs include a clunk over bumps, or a torn or walked-out bushing you can see. Press the new bushing square. A cocked bushing will tear in a few thousand miles. Read more

One part is listed for the 2017 Toyota RAV4 — TOPLINE PBD34.

This table covers the rings that seal each piston to the cylinder wall. Read more

5 Piston Ring parts for the 2017 Toyota RAV4 come from 4 brands — HASTINGS MANUFACTURING, MAHLE / CLEVITE, ITM ENGINE COMPONENTS and 1 other brand. The "Popular" part is HASTINGS MANUFACTURING 2C4132. 4 parts fit every engine; the other 1 is engine-specific.

Premium: 1 part, from MAHLE / CLEVITE. A representative part number is MAHLE / CLEVITE 42299CP.

Standard Replacement: 4 parts, from HASTINGS MANUFACTURING, ITM ENGINE COMPONENTS and TOPLINE. A representative part number is HASTINGS MANUFACTURING 2C4132.

Listed part numbers: HASTINGS MANUFACTURING 2C4132, MAHLE / CLEVITE 42299CP and HASTINGS MANUFACTURING 2C4132S, plus the other parts above.

This table covers the rocker arms that transfer cam motion to the valves. Read more

One part is listed for the 2017 Toyota RAV4 — MELLING MR906.

This table covers the Thrust washers. Read more

2 Thrust Washer parts are listed for the 2017 Toyota RAV4, from KING ENGINE BEARINGS and MAHLE / CLEVITE. 1 part fits every engine; the other 1 is engine-specific.

This group includes KING ENGINE BEARINGS TW1058AM and MAHLE / CLEVITE TW742S.

This table covers the timing chains that keep the cams in time with the crank. Read more

6 Timing Chain parts for the 2017 Toyota RAV4 come from 6 brands — MELLING, AISIN, CLOYES and 3 other brands. The "Popular" part is MELLING 1064. 4 parts fit every engine; the other 2 are engine-specific.

This group includes MELLING 1064, AISIN ETCT003 and CLOYES 94313 and the remaining parts above.