2020 Toyota RAV4 Engine Parts

This table covers the bearings in the connecting-rod big ends. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

This group shows a single part: TOPLINE RBTO59.

This table covers lower / conversion gasket sets for oil-pan and related joints. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

2 Conversion / Lower Gasket Set parts for the 2020 Toyota RAV4 come from 2 brands — AJUSA and TOPLINE. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: AJUSA 54307700 and TOPLINE CBSTO59.

This table covers the main bearings that support the crankshaft in the block. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

TOPLINE supplies both parts for the 2020 Toyota RAV4. All of them fit every engine offered in the 2020 RAV4.

This group includes TOPLINE TWTO59 and TOPLINE MBTO59.

This table covers the front and rear seals that keep oil in at the crankshaft. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

4 Crankshaft Seal parts are listed for the 2020 Toyota RAV4, from AJUSA and VICTOR REINZ. All of them fit every engine offered in the 2020 RAV4.

Part numbers include AJUSA 15121900, AJUSA 15092800 and VICTOR REINZ 811059200, among others listed above.

This table covers the bolts that clamp the cylinder head to the block. Read more

3 Cylinder Head Bolt parts for the 2020 Toyota RAV4 come from 3 brands — AJUSA, TOPLINE and VICTOR REINZ. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: AJUSA 81078800, TOPLINE HBTO59 and VICTOR REINZ 141786701.

This table covers the head gaskets that seal the block to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

4 Cylinder Head Gasket parts for the 2020 Toyota RAV4 come from 4 brands — AJUSA, APEX, MAHLE / CLEVITE and 1 other brand. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

This group includes AJUSA 10251200, APEX AHG891 and MAHLE / CLEVITE 55502 and the remaining parts above.

This table covers multi-piece gasket sets for a cylinder-head job. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

5 Cylinder Head Gasket Set parts for the 2020 Toyota RAV4 come from 4 brands — MAHLE / CLEVITE, AJUSA, TOPLINE and 1 other brand. 3 parts fit every engine; the other 2 are engine-specific.

Part numbers include AJUSA 52570500, MAHLE / CLEVITE HS55502 and MAHLE / CLEVITE HS55502A, among others listed above.

This table covers the Engine covers. Read more

6 Engine Cover parts for the 2020 Toyota RAV4 come from 2 brands — TECHPRO and VARIOUS MFR. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Part numbers include TECHPRO TO1228295, TECHPRO TO1228265 and TECHPRO TO1228240, among others listed above.

This table covers full gasket kits covering the joints opened in an engine rebuild. Typical signs include the leaks that sent the engine or gearbox to the bench. Use every gasket the set is meant for that opening — leftover unused pieces usually belong to another configuration. Read more

2 Engine Kit Gasket Set parts for the 2020 Toyota RAV4 come from 2 brands — AJUSA and TOPLINE. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: AJUSA 50522800 and TOPLINE CGSTO59.

This table covers the exhaust valves that let combustion gas out of the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

2 Exhaust Valve parts are listed for the 2020 Toyota RAV4, from MELLING and TOPLINE. All of them fit every engine offered in the 2020 RAV4.

Part numbers include MELLING V5831 and TOPLINE EVTO59.

This table covers the crankshaft pulleys / harmonic balancers at the front of the engine. Read more

5 Harmonic Balancer parts for the 2020 Toyota RAV4 come from 3 brands — ATP, PIONEER and ACKOJA.

Part numbers include ACKOJA A700993, ATP 102180 and ATP 102224, among others listed above.

This table covers the Intake manifolds. Typical signs include an exhaust tick, a vacuum leak, or a gasket that has burned through. Replace the gaskets and hardware; a warped flange will leak with a new gasket alone. Read more

One part is listed for the 2020 Toyota RAV4 — ACKOJA A700257.

This table covers the gaskets between the intake manifold and the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

4 Intake Manifold Gasket parts for the 2020 Toyota RAV4 come from 4 brands — AJUSA, BECK/ARNLEY, MAHLE / CLEVITE and 1 other brand. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: AJUSA 13316900, BECK/ARNLEY 0376251 and MAHLE / CLEVITE MS20603, plus the other parts above.

This table covers the intake valves that let air (and fuel, on port-injected engines) into the cylinder. Typical signs include a circuit that will not hold, a whistle, or a code for this valve. A stuck valve is often debris. Clean the ports before installing the new one. Read more

3 Intake Valve parts are listed for the 2020 Toyota RAV4, from MELLING, QUALCAST and TOPLINE. All of them fit every engine offered in the 2020 RAV4.

Listed part numbers: MELLING V5832, QUALCAST 1030532 and TOPLINE IVTO59.

This table covers the mounts that hold the engine to the chassis. Typical signs include a clunk on takeoff, a vibration at idle, or a separated rubber insert. Support the powertrain before unbolting a mount, and torque the fasteners in the notes. Read more

20 Motor Mount parts are listed for the 2020 Toyota RAV4, from ANCHOR, DEA / MARMON RIDE CONTROL, PIONEER and 1 other brand. ANCHOR 10196 carries the "Popular" badge. 5 parts fit every engine; the other 15 are engine-specific.

This table covers the Motor Mount kits. Read more

ANCHOR supplies the 3 Motor Mount Kit parts for the 2020 Toyota RAV4.

This group includes ANCHOR 300913, ANCHOR 300912 and ANCHOR 300977.

This table covers the engine oils listed by grade and specification for this engine. Typical signs include a low-oil lamp, knocking after a long interval, or oil that has gone thin and black well before the next service. Match the viscosity and spec in the notes (and on the filler cap). The tables group grades — they are not interchangeable. Read more

10 Oil parts are listed for the 2020 Toyota RAV4, from LIQUI MOLY, IDEMITSU, VALVOLINE and 1 other brand. LIQUI MOLY 20328 carries the "Popular" badge. All of them fit every engine offered in the 2020 RAV4.

In the Full Synthetic grade, LIQUI MOLY, VALVOLINE, IDEMITSU and 1 other brand supply 9 parts: full-synthetic oils. A representative part number is LIQUI MOLY 20328.

The High Mileage (>75,000 Miles) section lists 1 option from IDEMITSU — oils grouped for high-mileage engines. IDEMITSU 30015121750 is listed in this group.

This table covers the heat exchangers that cool engine oil. Typical signs include oil at the cooler fittings, or coolant that looks like a milkshake. Pressure-test both circuits after a cooler swap — a leak here mixes oil and coolant. Read more

3 Oil Cooler parts are listed for the 2020 Toyota RAV4, from ACKOJA, NISSENS and STANDARD MOTOR PRODUCTS. All of them fit every engine offered in the 2020 RAV4.

This group includes ACKOJA A70600016, NISSENS 91442 and STANDARD MOTOR PRODUCTS OCK57.

This table covers the seals at the Oil Dipstick / Tube. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

This group shows a single part: BECK/ARNLEY 0396661.

This table covers the drain plugs in the oil pan. Read more

5 Oil Drain Plug parts are listed for the 2020 Toyota RAV4, from DORMAN, AGS, BECK/ARNLEY and 1 other brand. DORMAN 090038 carries the "Popular" badge. All of them fit every engine offered in the 2020 RAV4.

Listed part numbers: DORMAN 090038, AGS ODP00011 and BECK/ARNLEY 0160116, plus the other parts above.

This table covers the crush washers and gaskets under the oil drain plug. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

5 Oil Drain Plug Gasket parts for the 2020 Toyota RAV4 come from 5 brands — DORMAN, APEX, FEL-PRO and 2 other brands. The "Popular" part is DORMAN 095156. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

This group includes DORMAN 095156, APEX ADP1902 and FEL-PRO 70822 and the remaining parts above.

This table covers the caps on the oil filler neck. Read more

3 Oil Filler Cap parts are listed for the 2020 Toyota RAV4, from CALORSTAT, GATES and MOTORAD. All of them fit every engine offered in the 2020 RAV4.

Part numbers include CALORSTAT OC2312, GATES 31285 and MOTORAD MO155.

This table covers the gaskets that seal the Oil Filler Cap. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

This group shows a single part: AJUSA 00519100.

This table covers the oil filters that screw onto this engine's filter mount. Typical signs include low oil pressure after a service, or a filter that will not spin off because the old gasket stayed on the block. Lube the new gasket and tighten to the spec on the box; a double-gasket install dumps the sump on the first drive. Read more

17 Oil Filter parts are listed for the 2020 Toyota RAV4, from VARIOUS MFR, BOSCH, FRAM and 11 other brands. VARIOUS MFR PG4476 carries the "Popular" badge. 13 parts fit every engine; the other 4 are engine-specific.

In the Economy grade, VARIOUS MFR, BOSCH, FRAM and 2 other brands supply 6 parts: the catalog's value-priced group. A representative part number is VARIOUS MFR PG4476.

In the High Performance / Heavy Duty grade, MOBIL supplies 1 part: grouped under the catalog's "High Performance / Heavy Duty" designation — the notes column spells out what sets them apart. A representative part number is MOBIL M1103A.

The Standard Replacement section lists 9 options from ACDELCO, DENSO, BECK/ARNLEY and 6 other brands — built to original-equipment specification. ACDELCO PF1233 is listed in this group.

1 ungrouped part is not assigned to a grade, with the same engine-level match.

This table covers the Oil Level sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

One part is listed for the 2020 Toyota RAV4 — VEMO V70720463.

This table covers the oil pans that hold the engine's oil sump. Read more

4 Oil Pan parts for the 2020 Toyota RAV4 come from 4 brands — ACKOJA, DORMAN, SKP and 1 other brand. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

This group includes ACKOJA A700990, DORMAN 266004 and SKP SK266004 and the remaining parts above.

This table covers the gaskets between the oil pan and the block. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

One part is listed for the 2020 Toyota RAV4 — VICTOR REINZ 703141410.

This table covers the Oil pumps. Typical signs include noise from the pump, no pressure, or fluid that never arrives at the outlet. Prime or fill the pump as the notes require. A dry start is a common way to kill a new unit. Read more

2 Oil Pump parts are listed for the 2020 Toyota RAV4, from AISIN and TOPLINE. All of them fit every engine offered in the 2020 RAV4.

Listed part numbers: AISIN OPT125 and TOPLINE OPTO59.

This table covers the chains that drive the oil pump. Read more

12 Oil Pump Chain parts for the 2020 Toyota RAV4 come from 6 brands — S.A. GEAR, MELLING, CLOYES and 3 other brands. The "Popular" part is MELLING 1084. 1 part fits every engine; the other 11 are engine-specific.

The Kit section lists 1 option from INA — grouped under the catalog's "Kit" designation — the notes column spells out what sets them apart. INA ZC0158 is listed in this group.

Standard Replacement: 5 parts, from S.A. GEAR, MELLING, CLOYES and 1 other brand. A representative part number is MELLING 1084.

6 further parts sit outside the graded sections, with the same engine-level match.

This table covers the Oil Pump Chain tensioners. Typical signs include belt flutter, a chirp that returns after a new belt, or an arm that no longer damps. Replace the tensioner with the belt at higher mileage. Read more

4 Oil Pump Chain Tensioner parts are listed for the 2020 Toyota RAV4, from CLOYES, MELLING, PREFERRED COMPONENTS INC and 1 other brand. All of them fit every engine offered in the 2020 RAV4.

Listed part numbers: CLOYES 96157, MELLING BT7064 and PREFERRED COMPONENTS INC T66361, plus the other parts above.

This table covers the Oil Pump Control Valve solenoids. Typical signs include a harsh or missing shift, or a code for this solenoid circuit. Check resistance and the connector before dropping the pan for a solenoid. Read more

This group shows a single part: GATES VVS398.

This table covers the Oil Pump sprockets. Read more

4 Oil Pump Sprocket parts for the 2020 Toyota RAV4 come from 4 brands — CLOYES, MELLING, PREFERRED COMPONENTS INC and 1 other brand. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Listed part numbers: CLOYES S1184, MELLING S1325 and PREFERRED COMPONENTS INC G57020, plus the other parts above.

This table covers the pistons that travel in each cylinder. Typical signs include knock, blow-by, or a cylinder that will not hold compression. Piston work is a short-block job. Match bore, pin and ring pack in the notes — not the photo. Read more

2 Piston parts for the 2020 Toyota RAV4 come from TOPLINE.

Part numbers include TOPLINE PATO59 and TOPLINE PATO59H.

This table covers the rings that seal each piston to the cylinder wall. Read more

This group shows a single part: TOPLINE RSTO59.

This table covers the timing chains that keep the cams in time with the crank. Read more

5 Timing Chain parts for the 2020 Toyota RAV4 come from 5 brands — S.A. GEAR, CLOYES, JAPANESE OE and 2 other brands. The "Popular" part is S.A. GEAR C1176. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

Part numbers include S.A. GEAR C1176, CLOYES C995 and JAPANESE OE A05078AM, among others listed above.

This table covers kits that group a timing chain with the related tensioners and guides. Read more

8 Timing Chain & Component Kit parts are listed for the 2020 Toyota RAV4, from S.A. GEAR, CLOYES, MELLING and 2 other brands. S.A. GEAR 76415 carries the "Popular" badge. All of them fit every engine offered in the 2020 RAV4.

Economy: 2 parts, from S.A. GEAR. A representative part number is S.A. GEAR 76415.

The Standard Replacement section: 6 options from CLOYES, MELLING, ENGINETECH and 1 other brand. CLOYES 90995SX is listed in this group.

Part numbers include S.A. GEAR 76415, S.A. GEAR 76415T and CLOYES 90995SX, among others listed above.

This table covers the guides and dampers that keep the timing chain on its path. Read more

6 Timing Chain Guide / Damper parts for the 2020 Toyota RAV4 come from 3 brands — S.A. GEAR, CLOYES and MELLING. The "Popular" part is S.A. GEAR 71257. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

This group includes S.A. GEAR 71257, S.A. GEAR 91341 and CLOYES 96158 and the remaining parts above.

This table covers the tensioners that keep the timing chain taut. Typical signs include belt flutter, a chirp that returns after a new belt, or an arm that no longer damps. Replace the tensioner with the belt at higher mileage. Read more

4 Timing Chain Tensioner parts are listed for the 2020 Toyota RAV4, from CLOYES, MELLING, PREFERRED COMPONENTS INC and 1 other brand. All of them fit every engine offered in the 2020 RAV4.

This group includes CLOYES 96154, MELLING BT7062 and PREFERRED COMPONENTS INC T66360 and the remaining parts above.

This table covers the crankshaft sprockets that drive the timing chain or belt. Read more

6 Timing Crank Sprocket parts are listed for the 2020 Toyota RAV4, from MELLING, S.A. GEAR and CLOYES. MELLING S1323 carries the "Popular" badge. All of them fit every engine offered in the 2020 RAV4.

Part numbers include MELLING S1323, S.A. GEAR S1469 and CLOYES S1187, among others listed above.

This table covers the Valve covers. Read more

This group shows a single part: APEX VCS891.

This table covers the gaskets that seal the valve cover to the cylinder head. Typical signs include seepage at the joint, a burnt-oil smell, or a leak that appears only after a long drive. Clean both flanges and torque in the sequence the notes or the manual call for. Read more

5 Valve Cover Gasket parts are listed for the 2020 Toyota RAV4, from BECK/ARNLEY, APEX, MAHLE / CLEVITE and 1 other brand. BECK/ARNLEY 0362105 carries the "Popular" badge. All of them fit every engine offered in the 2020 RAV4.

This group includes BECK/ARNLEY 0362105, APEX AVC891 and BECK/ARNLEY 0362084 and the remaining parts above.

This table covers the pressed-in bronze and cast-iron guides that align valve stems. Typical signs include oil smoke on startup, a guide that has gone oval, or a valve that no longer seats quietly. Guides are a machine-shop fit. Confirm stem diameter in the notes before ordering. Read more

One part is listed for the 2020 Toyota RAV4 — TOPLINE IVGTO55.

This table covers the lifters / tappets that transfer cam motion to the valves. Read more

2 Valve Lifter parts are listed for the 2020 Toyota RAV4, from AJUSA and TOPLINE. 1 part fits every engine; the other 1 is engine-specific.

Listed part numbers: AJUSA 85022700 and TOPLINE LIFTO59.

This table covers the springs that close each intake and exhaust valve. Typical signs include a sagging corner, a broken coil, or a clunk from the spring pocket. Replace springs in axle pairs and inspect the seats. Read more

4 Valve Spring parts for the 2020 Toyota RAV4 come from 2 brands — MELLING and QUALCAST. 2 parts fit every engine; the other 2 are engine-specific.

Listed part numbers: MELLING VS2508, MELLING VS2507 and QUALCAST 325507, plus the other parts above.

This table covers the Valve Spring retainers. Read more

This group shows a single part: MELLING VSR726.

This table covers the keepers that lock each valve-spring retainer to the stem. Read more

2 Valve Spring Retainer Keeper parts for the 2020 Toyota RAV4 come from 2 brands — MELLING and SBI. Every part fits both the 2.5L L4 and the 2.5L L4 ELECTRIC/GAS.

This group includes MELLING VL1100 and SBI 1211100.

This table covers the seals on each valve stem that control oil into the guides. Typical signs include a wet housing, a drip after sitting, or fluid flung off a rotating shaft. Fix the surface the seal rides on. A new seal on a grooved shaft will leak again. Read more

6 Valve Stem Seal parts are listed for the 2020 Toyota RAV4, from SBI, APEX, FEL-PRO and 2 other brands. APEX AVS8055 carries the "Popular" badge. 5 parts fit every engine; the other 1 is engine-specific.

Listed part numbers: APEX AVS8055, FEL-PRO SS728781 and SBI 1221266, plus the other parts above.

This table covers the oil-control solenoids that command the cam phasers. Typical signs include a door or range that will not move, or a click with no motion. Confirm the command signal before replacing the actuator — a failed module looks the same. Read more

5 Variable Valve Timing (VVT) Solenoid / Actuator parts are listed for the 2020 Toyota RAV4, from STANDARD MOTOR PRODUCTS, VAICO, WELLS and 1 other brand. AISIN OSVT9003 carries the "Popular" badge. All of them fit every engine offered in the 2020 RAV4.

Economy: 2 parts, from VAICO and WELLS. A representative part number is VAICO V700774.

The Standard Replacement section: 3 options from STANDARD MOTOR PRODUCTS and AISIN. AISIN OSVT9003 is listed in this group.

Part numbers include AISIN OSVT9003, VAICO V700774 and WELLS 2T1306, among others listed above.

This table covers the cam phaser sprockets used by the variable-valve-timing system. Read more

4 Variable Valve Timing (VVT) Sprocket parts are listed for the 2020 Toyota RAV4, from ACKOJA and STANDARD MOTOR PRODUCTS. All of them fit every engine offered in the 2020 RAV4.

This group includes ACKOJA A701014, ACKOJA A701036 and STANDARD MOTOR PRODUCTS VVT748 and the remaining parts above.