2016 Ford Fusion Electrical Parts

This table covers the alternators that charge the battery and run the electrical load. Typical signs include dim lights at idle, a battery lamp, or a growl from the charging pulley. Load-test the battery and inspect the belt and grounds — a bad ground mimics a failed alternator. Read more

49 Alternator / Generator parts for the 2016 Ford Fusion come from 11 brands — MOTORCRAFT, REMY, TERREPOWER and 8 other brands. The "Popular" part is MOTORCRAFT GL8840. Grades run from New through Remanufactured; Remanufactured is the most populated section, led by PURE ENERGY, BOSCH, REMY and 5 other brands.

This table covers the pulleys on the alternator shaft. Typical signs include a growl or chirp that follows engine speed, or a pulley that will not spin freely by hand. Spin each pulley with the belt off. Roughness or play means replace it with the belt. Read more

9 Alternator / Generator Pulley parts are listed for the 2016 Ford Fusion, from CONTINENTAL, LITENS, MOTORCRAFT and 1 other brand. MOTORCRAFT GP758 carries the "Popular" badge.

This group includes MOTORCRAFT GP758, MOTORCRAFT GP778 and CONTINENTAL 49947 and the remaining parts above.

This table covers the batteries listed by group size and specification. Typical signs include slow cranking, a battery lamp, or a no-start after the vehicle sat overnight. Confirm group size and terminal layout in the notes. Clean the posts and the ground before condemning the battery. Read more

8 Battery parts are listed for the 2016 Ford Fusion, from ACDELCO, DEKA, LUCAS and 4 other brands. ACDELCO 48AGM carries the "Popular" badge.

Part numbers include ACDELCO 48AGM, DEKA 9A48 and LUCAS LBAGM004A, among others listed above.

This table covers the positive and ground cables that run from the battery. Typical signs include a stretched or frayed cable, or a control that no longer reaches the end of its travel. Route the new cable through the same clips. A kinked cable binds and fails early. Read more

3 Battery Cable parts for the 2016 Ford Fusion come from MOTORCRAFT.

Part numbers include MOTORCRAFT WC96780, MOTORCRAFT WC96730 and MOTORCRAFT WC96285.

This table covers the Battery Cable Terminal ends. Read more

One part is listed for the 2016 Ford Fusion — MOTORCRAFT BCTE1.

This table covers the Battery Cooling fans. Typical signs include overheating at idle, a fan that never comes on, or a blade that hits the shroud. Confirm the fan command and the relay before replacing the assembly. Read more

3 Battery Cooling Fan parts are listed for the 2016 Ford Fusion, from FOUR SEASONS, GPD and VDO / CONTINENTAL.

Listed part numbers: FOUR SEASONS 76800, GPD 2312069 and VDO / CONTINENTAL PM9504.

This table covers the Battery Current sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

7 Battery Current Sensor parts for the 2016 Ford Fusion come from 3 brands — STANDARD MOTOR PRODUCTS, WELLS and DORMAN. The "Popular" part is STANDARD MOTOR PRODUCTS BSC9.

Part numbers include STANDARD MOTOR PRODUCTS BSC9, DORMAN 956135 and STANDARD MOTOR PRODUCTS BSC7, among others listed above.

This table covers the clamps and brackets that secure the battery. Read more

This group shows a single part: DORMAN 00588.

This table covers the terminals and clamps that connect cables to the battery posts. Read more

11 Battery Terminal parts are listed for the 2016 Ford Fusion, from MOTORCRAFT and DORMAN. DORMAN 926879 carries the "Popular" badge.

This table covers the Battery Terminal Bolt nuts. Read more

This group shows a single part: DORMAN 926875.

This table covers the Blind Spot Detection sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

2 Blind Spot Detection Sensor parts for the 2016 Ford Fusion come from 2 brands — STANDARD MOTOR PRODUCTS and WELLS.

This group includes STANDARD MOTOR PRODUCTS BSD31 and WELLS 5S16713.

This table covers the resettable circuit breakers in this vehicle's electrical system. Read more

18 Circuit Breaker parts are listed for the 2016 Ford Fusion, from MOTORCRAFT and STANDARD MOTOR PRODUCTS. MOTORCRAFT SW8879 carries the "Popular" badge.

This table covers the Cruise Control Distance sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

3 Cruise Control Distance Sensor parts are listed for the 2016 Ford Fusion, from DORMAN, STANDARD MOTOR PRODUCTS and WELLS.

Part numbers include DORMAN 601745, STANDARD MOTOR PRODUCTS CCD15 and WELLS 5S17079.

This table covers the flasher units that blink the turn signals and hazards. Read more

2 Flasher parts are listed for the 2016 Ford Fusion, from MOTORCRAFT and STANDARD MOTOR PRODUCTS.

Listed part numbers: MOTORCRAFT SW7691 and STANDARD MOTOR PRODUCTS EFL160.

This table covers the replacement fuses for this vehicle's fuse boxes. Typical signs include one circuit dead while its neighbor still works, or a fuse that blows again as soon as you replace it. Match amperage and fuse type. A repeat blow means a short — find it before the next fuse. Read more

31 Fuse parts are listed for the 2016 Ford Fusion, from BUSSMANN, LITTELFUSE and MOTORCRAFT. LITTELFUSE MIN15 carries the "Popular" badge. They are grouped as 10 Amp, 15 Amp, 175 Amp, 20 Amp, 200 Amp, 25 Amp, 250 Amp, 30 Amp, 40 Amp, 5 Amp, 50 Amp, 60 Amp and 7.5 Amp, with 30 Amp the largest group at 5 parts from BUSSMANN and LITTELFUSE.

This table covers the Fuse boxes. Read more

2 Fuse Box parts for the 2016 Ford Fusion come from MOTORCRAFT.

Listed part numbers: MOTORCRAFT HLS16 and MOTORCRAFT HLS17.

This table covers the Fuse Box covers. Read more

One part is listed for the 2016 Ford Fusion — MOTORCRAFT HLSC33.

This table covers the horns mounted in the front of the vehicle. Read more

14 Horn parts are listed for the 2016 Ford Fusion, from FIAMM, DORMAN and MOTORCRAFT. FIAMM 7210223 carries the "Popular" badge.

In the Accessory Replacement grade, FIAMM supplies 7 parts: grouped under the catalog's "Accessory Replacement" designation — the notes column spells out what sets them apart. A representative part number is FIAMM 7210223.

The Standard Replacement section lists 7 options from FIAMM, DORMAN and MOTORCRAFT — built to original-equipment specification. FIAMM 7200223 is listed in this group.

This table covers the key fobs that lock, unlock and start the vehicle. Read more

2 Keyless Entry Remote parts for the 2016 Ford Fusion come from DORMAN.

Part numbers include DORMAN 99097ST and DORMAN 99097.

This table covers the replacement shells for the key fob. Read more

3 Keyless Entry Remote Case parts for the 2016 Ford Fusion come from DORMAN.

Part numbers include DORMAN 95629, DORMAN 92066 and DORMAN 95353.

This table covers the ultrasonic park-aid sensors in the bumper. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

9 Parking Aid Sensor parts for the 2016 Ford Fusion come from 5 brands — STANDARD MOTOR PRODUCTS, MOTORCRAFT, SKP and 2 other brands. The "Popular" part is STANDARD MOTOR PRODUCTS PPS63.

This group includes STANDARD MOTOR PRODUCTS PPS63, STANDARD MOTOR PRODUCTS PPS19 and MOTORCRAFT PRKS5 and the remaining parts above.

This table covers the Side Object Sensor modules. Typical signs include a cluster of unrelated faults, a no-communication code, or a module that will not sleep. Confirm power, ground and programming compatibility in the notes. Modules are rarely plug-and-play across years. Read more

This group shows a single part: DORMAN 601277.

This table covers the speed sensors on the transmission, transfer case or ABS ring. Typical signs include a dead speedometer, harsh transmission shifts, or a code for vehicle speed. Inspect the tone wheel and the connector before replacing the sensor. Read more

21 Speed Sensor parts are listed for the 2016 Ford Fusion, from STANDARD MOTOR PRODUCTS, MOTORCRAFT, HOLSTEIN and 8 other brands. HOLSTEIN 2VSS0111 carries the "Popular" badge.

In the Economy grade, HOLSTEIN, GPD, ATP and 2 other brands supply 7 parts: the catalog's value-priced group. A representative part number is HOLSTEIN 2VSS0111.

The Standard Replacement section: 14 options from MOTORCRAFT, DELPHI, NTK and 4 other brands. MOTORCRAFT DY1253 is listed in this group.