2005 Toyota Highlander Electrical Parts

This table covers the alternators that charge the battery and run the electrical load. Typical signs include dim lights at idle, a battery lamp, or a growl from the charging pulley. Load-test the battery and inspect the belt and grounds — a bad ground mimics a failed alternator. Read more

16 Alternator / Generator parts are listed for the 2005 Toyota Highlander, from WAI GLOBAL, REMY, TERREPOWER and 5 other brands. WAI GLOBAL 11034N carries the "Popular" badge.

In the New grade, WAI GLOBAL, ACDELCO, REMY and 1 other brand supply 5 parts: brand-new units rather than rebuilt ones. A representative part number is WAI GLOBAL 11034N.

In the Remanufactured grade, TERREPOWER, PURE ENERGY, REMY and 5 other brands supply 11 parts: factory-rebuilt units with new wear components. A representative part number is DENSO 2100550.

This table covers the bearings in the alternator housing. Typical signs include a growl that rises with speed, or play in the shaft or hub. Set preload the way the notes specify. A dry or crushed bearing fails quickly. Read more

3 Alternator / Generator End Bearing parts for the 2005 Toyota Highlander come from 3 brands — WJB / INMOTION PARTS, BCA and NATIONAL.

The Economy section lists 1 option from WJB / INMOTION PARTS — the catalog's value-priced group. WJB / INMOTION PARTS RB63032RS is listed in this group.

In the Standard Replacement grade, BCA and NATIONAL supply 2 parts: built to original-equipment specification. A representative part number is BCA NB303CC.

This group includes WJB / INMOTION PARTS RB63032RS, BCA NB303CC and NATIONAL 303CC.

This table covers the pulleys on the alternator shaft. Typical signs include a growl or chirp that follows engine speed, or a pulley that will not spin freely by hand. Spin each pulley with the belt off. Roughness or play means replace it with the belt. Read more

This group shows a single part: DAYCO 892005.

This table covers the Automatic Headlamp sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

3 Automatic Headlamp Sensor parts for the 2005 Toyota Highlander come from 3 brands — AUTOTECNICA, STANDARD MOTOR PRODUCTS and WELLS.

This group includes AUTOTECNICA TY1321529, STANDARD MOTOR PRODUCTS EFL165 and WELLS 5S8091.

This table covers the batteries listed by group size and specification. Typical signs include slow cranking, a battery lamp, or a no-start after the vehicle sat overnight. Confirm group size and terminal layout in the notes. Clean the posts and the ground before condemning the battery. Read more

6 Battery parts for the 2005 Toyota Highlander come from 4 brands — DEKA, EXIDE, FULLRIVER and 1 other brand. The "Popular" part is DEKA 9A3585.

Listed part numbers: DEKA 9A3585, DEKA 9A34R and DEKA 9A24F, plus the other parts above.

This table covers the clamps and brackets that secure the battery. Read more

One part is listed for the 2005 Toyota Highlander — SKP SK7440402K.

This table covers the terminals and clamps that connect cables to the battery posts. Read more

5 Battery Terminal parts for the 2005 Toyota Highlander come from 4 brands — DEKA, BECK/ARNLEY, DORMAN and 1 other brand. The "Popular" part is DEKA 01056.

Listed part numbers: DEKA 01056, BECK/ARNLEY 2060001 and DEKA 00350, plus the other parts above.

This table covers the flasher units that blink the turn signals and hazards. Read more

3 Flasher parts for the 2005 Toyota Highlander come from 3 brands — STANDARD MOTOR PRODUCTS, TRIDON / NOVITA and WELLS.

This group includes STANDARD MOTOR PRODUCTS EFL55, TRIDON / NOVITA LM449 and WELLS 1R2247.

This table covers the replacement fuses for this vehicle's fuse boxes. Typical signs include one circuit dead while its neighbor still works, or a fuse that blows again as soon as you replace it. Match amperage and fuse type. A repeat blow means a short — find it before the next fuse. Read more

26 Fuse parts for the 2005 Toyota Highlander come from 2 brands — BUSSMANN and LITTELFUSE. The "Popular" part is BUSSMANN ATM10. They are grouped as 10 Amp, 15 Amp, 20 Amp, 25 Amp, 30 Amp, 40 Amp, 50 Amp and 7.5 Amp, with 10 Amp the largest group at 5 parts from LITTELFUSE and BUSSMANN.

This table covers the horns mounted in the front of the vehicle. Read more

11 Horn parts for the 2005 Toyota Highlander come from FIAMM. The "Popular" part is FIAMM 7210223.

The Accessory Replacement section lists 7 options from FIAMM — grouped under the catalog's "Accessory Replacement" designation — the notes column spells out what sets them apart. FIAMM 7210223 is listed in this group.

Standard Replacement: 4 parts, from FIAMM. A representative part number is FIAMM 7250522.

This table covers the key fobs that lock, unlock and start the vehicle. Read more

One part is listed for the 2005 Toyota Highlander — DORMAN 99137.

This table covers the replacement shells for the key fob. Read more

One part is listed for the 2005 Toyota Highlander — DORMAN 13631.

This table covers the speed sensors on the transmission, transfer case or ABS ring. Typical signs include a dead speedometer, harsh transmission shifts, or a code for vehicle speed. Inspect the tone wheel and the connector before replacing the sensor. Read more

13 Speed Sensor parts for the 2005 Toyota Highlander come from 12 brands — STANDARD MOTOR PRODUCTS, HOLSTEIN, BECK/ARNLEY and 9 other brands. The "Popular" part is HOLSTEIN 2VSS0045.

The Economy section: 7 options from HOLSTEIN, BECK/ARNLEY, DORMAN and 4 other brands. HOLSTEIN 2VSS0045 is listed in this group.

Standard Replacement: 6 parts, from AISIN, DELPHI, NTK and 3 other brands. A representative part number is AISIN RST0091.

This table covers the starter motors that crank the engine. Typical signs include no motion, a squeal, or a motor that only runs on one speed. Confirm power, ground and the control module before replacing the motor. Read more

16 Starter Motor parts are listed for the 2005 Toyota Highlander, from TERREPOWER, WAI GLOBAL, BOSCH and 7 other brands. TERREPOWER N17825 carries the "Popular" badge.

New: 8 parts, from TERREPOWER, ULTRA-POWER, WAI GLOBAL and 5 other brands. A representative part number is TERREPOWER N17825.

Remanufactured: 8 parts, from DENSO, ACDELCO, BOSCH and 5 other brands. A representative part number is DENSO 2800322.

This table covers the Starter solenoids. Typical signs include a harsh or missing shift, or a code for this solenoid circuit. Check resistance and the connector before dropping the pan for a solenoid. Read more

2 Starter Solenoid parts are listed for the 2005 Toyota Highlander, from STANDARD MOTOR PRODUCTS and WELLS.

This group includes STANDARD MOTOR PRODUCTS SS770 and WELLS 1M1432.

This table covers the regulators that control alternator output voltage. Read more

This group shows a single part: WELLS 1V1181.

This table covers the Yaw sensors. Typical signs include a warning lamp, a stored code, or a reading that drops out when the harness is wiggled. Inspect the connector and ground before replacing the sensor — wiring faults are often condemned as bad sensors. Read more

This group shows a single part: WELLS 5S13448.